Mighty Eagle

The Mighty Eagle (also known as the Warm Gas Test Article) is a prototype robotic lander developed by NASA at the Marshall Space Flight Center in Huntsville, Alabama.[2]

Not to be confused with the Angry Birds character with the same name.
Mighty Eagle lander
DescriptionSizeRef
Dry mass207 kg[1]
Descent thrusters3 total[1]
Descent thrust (each)60 lbf[1]
ACS thrusters12 total[1]
ACS thrust (each)10 lbf[1]
Max propellant mass116 kg[1]
PropellantH2O2[2]
PressurisationNitrogen[3]
Height4 ft[2]
Diameter8 ft[2]
Payload3D camera[4]

The vehicle is an autonomous flying testbed that is used for testing hardware, sensors and algorithms. These sensors and algorithms include such things as onboard cameras that, with specialized guidance, navigation and control software, could aid in the capture of orbiting space debris, in-space docking with a fuel depot, docking of a robotic lander with an orbiting command module and the rendezvous of multiple unmanned stages for deep space human exploration of the Solar System.[5]

History

Initial software and hardware development were done on precursor vehicle called the Cold Gas Test Article which used compressed air as a propellant and had about 10 seconds of flight time. The knowledge gained from this development and testing was used in the design of the Mighty Eagle.[1]

The Mighty Eagle prototype lander was developed by the Marshall Center and Johns Hopkins University Applied Physics Laboratory. Key partners in this project include the Von Braun Center for Science and Innovation, the Science Applications International Corporation, Dynetics Corporation and Teledyne Brown Engineering.[2]

The design of the vehicle began in late 2009 and integration was completed in January 2011. The vehicle was transported to an indoor test facility and bolted to the ground for initial testing, followed by free flight testing. Outdoor testing at another facility ran from August to November 2011. In 2012, a test area at MSFC was developed and the Mighty Eagle tested "Autonomous Rendezvous and Capture" technology. In 2013, enhancements were made including legs that are lighter by about 6.8 kg (15 lbs), a 3D stereo camera that allows the detection and avoidance of 3D (three dimensional) objects and an onboard image processor in preparation for "hazard avoidance" testing.[4] [6]

In July 2013 a hazard field (test area for the lander) consisting of 200 tons of lunar simulant began construction at the Marshall Space Flight Center.[7]

In August 2013 the hazard field was completed. The 3D camera was installed in an enclosure on the vehicle permitting the camera to be pointed at three different angles.[8]

After many tests (described below) the Mighty Eagle lander was put into "organization and storage" in December 2013. [9] Information from the NASA Robotic Lunar Lander Development Project (aka Mighty Eagle) was merged into the Lunar CATALYST initiative.[10]

For further details see Robotic Lunar Lander Development Project.[11]

The lander is named after the Mighty Eagle character, who originated from the Angry Birds video game.[12]

Specifications

Three-legged "green" lander:[2]

  • Fuel - 90 percent pure hydrogen peroxide[2]
  • Main thrust is provided by an EGC (Earth Gravity Cancelling) thruster giving 500 pounds-force (2,200 N) to 700 pounds-force (3,100 N) of thrust[1][13]
  • High purity nitrogen stored at ~3000 psi is regulated down to ~750 psi and is used to push the peroxide out of the thrusters. The vehicle can carry 7 kilograms (15 lb) of pressurant.[3][14]
  • Twelve Attitude Control System (ACS) thrusters each giving 10 pounds-force (44 N) of thrust provide attitude control[1]
  • 3D camera[2][4] which was given its own battery as part of the 200th modification to the vehicle.[15]
  • Onboard computer responsible for execution of pre-programmed flight profiles[2]
  • Dimensions - 4 feet (1.2 m) tall and 8 feet (2.4 m) in diameter[2]
  • Mass - when fuelled is ~700 pounds (320 kg)[2][16]
  • Performs vertical take off and vertical landings (VTVL)[17]

For additional information see the Robotic Lunar Lander information pages.[2][17]

Engines
Main thruster of the NASA Mighty Eagle

The NASA Mighty Eagle produces thrust by the violent decomposition of hydrogen peroxide (H2O2) using silver as a catalyst.[18]

Peroxide decomposition catalyst plate in main thruster

Testing

Prior to the flight tests, each subsystem was testing individually including the propulsion system.[13]

Flight tests in 2011
  • January 2011 - NASA engineers successfully integrated and completed system testing on a new robotic lander at Teledyne Brown Engineering's facility in Huntsville. Part of the testing involved placing the robotic lander prototype on modified skateboards and a customized track system. This low-cost solution controlled movement during the final testing of the prototype's sensors, onboard computer and thrusters.[19][20]
  • June 13, 2011 - indoor free (untethered) flight to 7 feet for 27 seconds.[21]
  • June 16, 2011 - Second free flight including a hover at 6 feet with controlled descent. The inertial measurement unit and radar altimeter were used to control the flight.[22]
  • August 23, 2011 - Performed a translated manoeuvre, (i.e. moved itself sideways) to execute a controlled, safe landing 13 feet from the launch pad.[23]
  • October–November 2011 - the Robotic Lander Development Project from NASA's Marshall Space Flight Center in Huntsville performed a series of complex tests on the prototype lander. At the Redstone Test Center's propulsion test facility on the U.S. Army Redstone Arsenal in Huntsville, Alabama the machine flew to three feet, then 30 feet, and finally a record 100-foot flight test. The flight lasted 30 seconds.[24]

Summer 2012 tests

"These lander tests provide the data necessary to expand our capabilities to go to other destinations".[2]

  • August 8, 2012 - Mighty Eagle flew to a height of 100 feet (30 m) and landed safely.[2]
  • August 28, 2012 - flew to a height of 100 feet (30 m). During the 35 second flight the lander automatically identified its destination 10 m away, flew there and landed safely.[12]
  • September 5, 2012 - flew to a height of 100 feet (30 m), used an onboard camera to identify an on-the-ground target and then autonomously landed itself at the chosen spot. Deliberately only carrying 103 kilograms (227 lb) of fuel this time.[25]
  • October 19, 2012 - WGTA tethered test of software changes.[26]
  • October 25, 2012 - Flew to a height of 50 metres (160 ft), above the tree tops.[27]

2013 tests

A hazard field test area that simulates the lunar surface, including boulders, is being prepared.[28] Amongst the test software and hardware modifications was procurement of a quadcopter whose WIFI camera can film midflight.[29]

  • April 10, 2013 - Regression test flight to three feet with lighter legs. The vehicle's three legs were tethered to the ground.[4][6][30]
  • April 19, 2013 - Free flight test with hundreds of student spectators. The flight was filmed with a quadcopter.[16][31]
  • August 30, 2013 - Tethered test flight with the 3D camera in its new point-able enclosure.[32]
  • September 16, 2013 - HAZ02 A free flight across the Hazard Field. 110.02 kg of propellant pressurised to 760 psi was loaded. The flight was successful, although dust was kicked up the vehicle was able to take a reconnaissance photograph of the Hazard Field. Modifications were made to the vehicle because test data from the practice flight on September 4, 2013, showed that there was insufficient power for the camera and intermittently the EGC throttle motor does not fully open.[15] The flight can be seen in this video taken from a quadcopter.[33]
  • September 20, 2013 HAZ03 - A free flight across the Hazard Field. The field had been watered to reduce dust. Guidance software from Moon Express was also carried to test to see if its outputs matched those of the NASA Guidance Software.[15]: September 20, 2013 [34]
  • September 26, 2013 Repeat of HAZ02. Mighty Eagle flew at a height of 20m and translating 45m.[15]: September 26, 2013  Moving pictures of the flight can be seen in this documentary.[35]
  • October 24, 2013 Test sequence HAZ05 was flown. This simulated a real landing by NASA Mighty Eagle ascending to 30m followed by a descending to 20m while translating and taking stereo images across the field. Only 100 kg of propellant were loaded.[36]: October 24, 2013  The flight can be seen in this video, including the steam/fog cloud produced by the cold.[37]
  • November 14, 2013 Tethered Test flight with modifications. Only 42.06 kg of propellant loaded. The normal software was replaced by guidance software form Moon Express. The Nanolaunch team supplied a secondary payload including several low-cost Inertial measurement units and Global Positioning System sensors for in flight characterization and algorithm testing.[38][39]: November 14, 2013 
  • November 25, 2013 Test MEG02 The vehicle flew to a height of three meters at a vertical velocity of 0.5 m/s, followed by a 12-second hover and finished with a descent at -1 m/s under the control of the Moon Express software.[40]

Further details about the tests and hardware can be found in the "Mighty Eagle: The Development and Flight Testing of an Autonomous Robotic Lander Test Bed" article in Johns Hopkins APL Technical Digest.[3]

Video

Entire NASA MSFC Mighty Eagle YouTube playlist (official).

See also

References
  1. Barbara A. Cohen (February 6, 2012). "EAS Lander talk" (PDF). NASA's Robotic Lunar Lander Development Project. NASA. Retrieved March 6, 2013.
  2. "NASA's 'Mighty Eagle' Robotic Prototype Lander Flies Again at Marshall". NASA. Archived from the original on September 16, 2012. Retrieved August 14, 2012.
  3. Timothy G. McGee; David A. Artis; Timothy J. Cole; Douglas A. Eng; Cheryl L. B. Reed; Michael R. Hannan; D. Greg Chavers; Logan D. Kennedy; Joshua M. Moore; Cynthia D. Stemple (2013). "Mighty Eagle: The Development and Flight Testing of an Autonomous Robotic Lander Test Bed" (PDF). Johns Hopkins Apl Technical Digest. 32 (3): 619–635. Retrieved December 29, 2013.
  4. "What's up, three-eyes? Here's the business side of our stereo camera (with optional 3rd camera)". NASA and Twitter. February 20, 2013. Retrieved April 2, 2013.
  5. "NASA Historic Test Stands Make Way for New Reusable Robotic Lander Neighbour". NASA. Archived from the original on September 25, 2012. Retrieved August 14, 2012.
  6. "Old lander, new legs, with a weight savings of ~6.8 kg (15 lbs)!". NASA and Twitter. April 2, 2013. Retrieved April 2, 2013.
  7. "Simulant Math". Twitter. NASA. Retrieved July 16, 2013.
  8. "NASA Mighty Eagle postings in August 2013". Facebook. NASA. Retrieved September 2, 2013.
  9. "With this (curved) picture, the organization and storage of Mighty Eagle hardware is complete! Now we wait..." Twitter. NASA. Retrieved May 29, 2014.
  10. "Lunar CATALYST References". NASA website. NASA. Retrieved May 29, 2014.
  11. "Robotic Lunar Lander Development Project" (PDF). NASA. Retrieved August 14, 2012.
  12. Lee Mohon, Jennifer Stanfield. "NASA's 'Mighty Eagle' Robotic Prototype Lander Takes 100-Foot Free Flight". NASA. Archived from the original on August 30, 2012. Retrieved August 31, 2012.
  13. "NASA Thruster Test Aids Future Robotic Lander's Ability to Land Safely". NASA. Retrieved April 2, 2013.
  14. "Twitter dated 10 April 2013 at 16:17 BST". Mighty Eagle. NASA and Twitter. Retrieved April 16, 2013.
  15. "Mighty Eagle posts on Facebook in September 2013". Facebook. NASA. Retrieved September 16, 2013.
  16. "Mighty Eagle gets a new view". NASA. Retrieved June 6, 2013.
  17. "Lunar Quest - Robotic". NASA. Archived from the original on December 27, 2011. Retrieved August 14, 2012.
  18. "Here's our workhorse Earth Gravity Cancelling thruster with its heat shield removed for inspection". NASA. Retrieved June 6, 2013.
  19. "Robotic Lander Prototype". NASA. January 26, 2011. Archived from the original on April 6, 2012. Retrieved April 2, 2013.
  20. "Robotic Lander Prototype". NASA. Archived from the original on April 6, 2012. Retrieved April 2, 2013.
  21. "NASA's Robotic Lander Takes Flight". NASA. June 16, 2011. Archived from the original on December 13, 2011. Retrieved April 2, 2013.
  22. "NASA's Robotic Lander Performs Second Free-Flight Test". NASA. June 21, 2011. Retrieved April 2, 2013.
  23. "NASA's Next Generation Robotic Lander Gets Sideways During Test". NASA. August 23, 2011. Retrieved April 2, 2013.
  24. "NASA Flies Robotic Lander Prototype to New Heights". NASA. November 21, 2011. Retrieved April 2, 2013.
  25. Adam Mann (2012-09-07). "NASA's Newest Autonomous Lander Passes Flight Test". Wired. Wired.com. Retrieved October 24, 2012.
  26. @NASAMightyEagle, ARC01A. "Tethered today, but not for long!". NASA. Retrieved October 24, 2012.
  27. @NASAMightyEagle. "Mighty Eagle rocks the treetops!". NASA. Retrieved October 25, 2012.
  28. "Mighty Eagle team having a hazard field meeting with the facilities office. The orange cones the future field". NASA and Twitter. March 13, 2013. Retrieved March 15, 2013.
  29. "Collage time: How could we improve test day video? Team with a quadcopter and have it shoot video midflight!". NASA and Twitter. April 2, 2013. Retrieved April 2, 2013.
  30. "2013 is off to a great start for the Mighty Eagle team!". NASA and Twitter. Retrieved April 16, 2013.
  31. Adam Kimberlin. "NASA Mighty Eagle Test Flight Video from UAV". NASA and YouTube. Retrieved April 21, 2013.
  32. "Test was a success. Great a Job Team MSFC! Mighty Eagle has Flown and Landed!!!!". Twitter. NASA. Retrieved September 2, 2013.
  33. "Mighty Eagle Hazard Avoidance Flight". YouTube. NASA. Retrieved September 16, 2013.
  34. "Midair with no dust. Should have gotten a bunch of stereo camera pictures of the hazard field". Twitter - NASAMIGHTYEAGLE. NASA. Retrieved September 26, 2013.
  35. "Three New ISS Residents on This Week @NASA ..." YouTube - NASAtelevision. NASA. Retrieved October 1, 2013.
  36. "Mighty Eagle posts on Facebook in October 2013". Facebook. NASA. Retrieved October 24, 2013.
  37. "Mighty Eagle Flight - Quadcopter stabilized video - 10/24/13". YouTube - Team Aero-M. NASA. Retrieved October 24, 2013.
  38. "In more interesting news, we'll have a secondary payload from the Nanolaunch team on this flight (grey box in pic)". Twitter. NASA. Retrieved November 15, 2013.
  39. "Mighty Eagle posts on Facebook in November 2013". Facebook. NASA. Retrieved November 15, 2013.
  40. "3m altitude achieved". Twitter - NASA Mighty Eagle. NASA. Retrieved November 29, 2013.
Wikimedia Commons has media related to Mighty Eagle.
This article is issued from Wikipedia. The text is licensed under Creative Commons - Attribution - Sharealike. Additional terms may apply for the media files.