SpaceX reusable launch system development program
SpaceX is privately funding the development of orbital launch systems that can be reused many times, in a manner similar to the reusability of aircraft. SpaceX has been developing the technologies over several years to facilitate full and rapid reusability of space launch vehicles. The project's long-term objectives include returning a launch vehicle first stage to the launch site in minutes and to return a second stage to the launch pad following orbital realignment with the launch site and atmospheric reentry in up to 24 hours. SpaceX's long term goal is that both stages of their orbital launch vehicle will be designed to allow reuse a few hours after return.[1]
![]() Falcon 9 Flight 20's first stage landing vertically on Landing Zone 1 in December 2015 | |
Program overview | |
---|---|
Country | United States |
Organization | SpaceX |
Purpose | Reusable launch system |
Status | Active |
Program history | |
Duration | 2011–present |
First flight | SpaceX CRS-3 |
Launch site(s) |
|
Vehicle information | |
Launch vehicle(s) |
Part of a series on |
Private spaceflight |
---|
Active companies |
|
Active vehicles |
|
Contracts and programs |
|
|
The program was publicly announced in 2011. SpaceX first achieved a successful landing and recovery of a first stage in December 2015. The first re-flight of a landed first stage occurred in March 2017[2] with the second occurring in June 2017, that one only five months after the maiden flight of the booster.[3] The third attempt occurred in October 2017 with the SES-11/EchoStar-105 mission. Reflights of refurbished first stages then became routine. In May 2021, B1051 became the first booster to power ten missions.[4]
The reusable launch system technology was developed and initially used for the first stage of Falcon 9.[5] After stage separation, the booster flips around, an optional boostback burn is done to reverse its course, a reentry burn, controlling direction to arrive at the landing site and a landing burn to effect the final low-altitude deceleration and touchdown.
SpaceX intended (from at least 2014) to develop technology to extend reusable flight hardware to second stages, a more challenging engineering problem because the vehicle is travelling at orbital velocity.[6][5][7] Second stage reuse is considered paramount to Elon Musk's plans to enable the settlement of Mars. Initial concepts to make the second stage of Falcon 9 reusable have been abandoned.[8]
As of 2021, SpaceX is actively developing the Starship system, with the intent to make it a fully-reusable two-stage launch vehicle, intended to replace all of its existing launch vehicles and spacecraft used for satellite delivery and human transport—Falcon 9, Falcon Heavy and Dragon—and also eventually support flights to the Moon and Mars. In addition it could be used for point-to-point transportation on Earth.[9]
History
![](../I/Falcon_rocket_family6.svg.png.webp)
SpaceX initially attempted to land the first stage of the Falcon 1 by parachute, however the stage did not survive the re-entry into the atmosphere. They continued to experiment unsuccessfully with parachutes on the earliest Falcon 9 flights after 2010. SpaceX subsequently switched its focus to developing a powered descent landing system.[10]
The broad outline of the reusable launch system was first publicly described in September 2011. SpaceX said it would attempt to develop powered descent and recovery of both Falcon 9 stages—a fully vertical takeoff, vertical landing (VTVL) rocket. The company produced a computer-animated video depicting a notional view of the first stage returning tail-first for a powered descent and the second stage with a heat shield, reentering head first before rotating for a powered descent.[11][12][13][14] In September 2012, SpaceX began flight tests on a prototype reusable first stage with the suborbital Grasshopper rocket.[15] Those tests continued into 2014, including testing of a second and larger prototype vehicle, F9R Dev1.
News of the Grasshopper test rocket had become public a few days earlier, when the US Federal Aviation Administration released a draft Environmental Impact Assessment for the SpaceX Test Site in Texas, and the space media had reported it.[16][17] In May 2012, SpaceX obtained a set of atmospheric test data for the recovery of the Falcon 9 first stage based on 176 test runs in the NASA Marshall Space Flight Center wind tunnel test facility. The work was contracted for by SpaceX under a reimburseable Space Act Agreement with NASA.[18]
In 2012, it was projected that the first-stage separation of a reusable Falcon 9 rocket would occur at a velocity of approximately Mach 6 (4,600 mph; 2.0 km/s) rather than Mach 10 (7,600 mph; 3.4 km/s) for an expendable Falcon 9, to provide the residual fuel necessary for the deceleration and turnaround maneuver and the controlled descent and landing.[1]
In November 2012, CEO Elon Musk announced SpaceX's plans to build a second, much larger, reusable rocket system, this one to be powered by LOX/methane rather than LOX/RP-1 used on Falcon 9 and Falcon Heavy. The new system was to be "an evolution of SpaceX's Falcon 9 booster", and SpaceX reiterated their commitment to develop a breakthrough in vertical landing technology.[19] By the end of 2012, the demonstration test vehicle, Grasshopper, had made three VTVL test flights—including a 29-second hover flight to 40 meters (130 ft) on December 17, 2012.[15] In early March 2013, SpaceX successfully tested Grasshopper for a fourth time when it flew to an altitude of over 80 meters (260 ft).[20]
In March 2013, SpaceX announced that it would instrument and equip subsequent Falcon 9 first-stages as controlled descent test vehicles, with plans for over-water propulsively decelerated simulated landings beginning in 2013, with the intent to return the vehicle to the launch site for a powered landing—possibly as early as mid-2014.[21] The April 2013 draft Environmental Impact Statement for the proposed SpaceX South Texas Launch Site includes specific accommodations for return of the Falcon 9 first-stage boosters to the launch site.[22] Elon Musk first publicly referred to the reusable Falcon 9 as the Falcon 9-R in April 2013.[23]
In September 2013, SpaceX successfully relit three engines of a spent booster on an orbital launch, and the booster re-entered the atmosphere at hypersonic speed without burning up.[24] With the data collected from the first flight test of a booster-controlled descent from high altitude, coupled with the technological advancements made on the Grasshopper low-altitude landing demonstrator, SpaceX announced it believed it was ready to test a full land-recovery of a booster stage.[25] Based on the positive results from the first high-altitude flight test, SpaceX advanced the expected date of a test from mid-2014 to early 2015, with the intention of doing so on the next Space Station cargo resupply flight pending regulatory approvals.[26][27] That flight took place on April 18, 2014.[28][29]
Musk stated in May 2013 that the goal of the program is to achieve full and rapid reusability of the first stage by 2015, and to develop full launch vehicle reusability following that as "part of a future design architecture".[30] In September 2013, SpaceX said that if all aspects of the test program were successful and if a customer is interested, the first reflight of a Falcon 9 booster stage could happen as early as late 2014.[26]
In February 2014, SpaceX made explicit that the newly defined super-heavy launch vehicle for what was then called Mars Colonial Transporter would also make use of the reusable technology.[7] This was consistent with Musk's strategic statement in 2012 that "The revolutionary breakthrough will come with rockets that are fully and rapidly reusable. We will never conquer Mars unless we do that. It'll be too expensive. The American colonies would never have been pioneered if the ships that crossed the ocean hadn't been reusable."[31]
Also in May 2014, SpaceX publicly announced an extensive test program for a related reusable technology: a propulsively landed space capsule called DragonFly. The tests were to be run in Texas at the McGregor Rocket Test Facility in 2014–2015.[32]
In June 2014, COO Gwynne Shotwell clarified that all funding for development and testing of the reusable launch system technology development program is private funding from SpaceX, with no contribution by the US government.[33] [34] As of 2017 SpaceX had spent over a billion dollars on the development program.[35]
For the first time, SpaceX stated in July 2014 that they are "highly confident of being able to land successfully on a floating launch pad or back at the launch site and refly the rocket with no required refurbishment."[36]
By late 2014, SpaceX suspended or abandoned the plan to recover and reuse the Falcon 9 second stage;[37] the additional mass of the required heat shield, landing gear, and low-powered landing engines would incur too great a performance penalty. While the idea was mentioned again later it was ultimately abandoned as Starship development made progress.[8]
In December 2015, following the recovery of the first stage from December 22 launch, SpaceX projected that the first reflight of a recovered booster would likely occur in 2016, but that their plan was to not refly the December 22 recovered stage for that purpose.[38]
In September 2016, SpaceX announced that development was underway to extend the reusable flight hardware to second stages, a more challenging engineering problem because the vehicle is travelling at orbital velocity. The reusable technology was to have been extended to the 2016 designs of both the tanker and crewed spaceship upper stage variants as well as the first stage of the Interplanetary Transport System,[6][5][7] and is considered paramount to the plans Elon Musk is championing to enable the settlement of Mars.[39][40][41] In 2016, initial test flights of an Interplanetary Transport System vehicle were expected no earlier than 2020.[6]
In 2017 SpaceX was making test flight progress in incrementally and iteratively developing a fairing recovery system.[42][2] In July 2017, Musk said "we are quite close to being able to recover the fairing. ... We've got a decent shot of recovering a fairing by the end of the year, and reflight by late this year or early next."[43] The cost savings to SpaceX of recovering the fairing is expected to be on the order of US$5 million. Together, the booster stage and the fairing make up approximately 80 percent of the cost of a launch.[43] The fairings are equipped with a steerable parachute and fall towards a ship equipped with a big net.[44] Intact fairings could be recovered from the ocean starting in 2017,[45] with landings in the net from 2019 on.[44]
Technologies
Several new technologies needed to be developed and tested to facilitate successful launch and recovery of the first stages of Falcon 9 and Falcon Heavy, and both stages of Starship. Since 2017, recovery and reuse of Falcon rocket boosters has become routine.
![](../I/Falcon_9_1st_stage_re-entry_with_grid_fins%253B_DSCOVR_mission_(16849254595).png.webp)
The technologies that were developed for Falcon 9, some of which are still being refined, include:
- Restartable ignition system for the first-stage booster.[23] Restarts are required at both supersonic velocities in the upper atmosphere—in order to reverse the high velocity away from the launch pad and put the booster on a descent trajectory back toward the launch pad—and at high transonic velocities in the lower atmosphere—in order to slow the terminal descent and to perform a soft landing.[46] If the booster returns to a landing site on land another burn is needed shortly after stage separation to reverse the flight direction of the booster, for a total of four burns for the center engine.
- New attitude control technology for the booster to bring the descending rocket body through the atmosphere in a manner conducive both to non-destructive return and sufficient aerodynamic control such that the terminal phase of the landing is possible.[47] This includes sufficient roll control authority to keep the rocket from spinning excessively as occurred on the first high-altitude flight test in September 2013, where the roll rate exceeded the capabilities of the booster attitude control system (ACS) and the fuel in the tanks "centrifuged" to the side of the tank shutting down the single engine involved in the low-altitude deceleration maneuver.[27][48] The technology needs to handle the transition from the vacuum of space at hypersonic conditions, decelerating to supersonic velocities and passing through transonic buffet, before relighting one of the main-stage engines at terminal velocity.[25]
- Hypersonic grid fins were added to the booster test vehicle design beginning on the fifth ocean controlled-descent test flight in 2014 in order to enable precision landing. Arranged in an "X" configuration, the grid fins control the descending rocket's lift vector once the vehicle has returned to the atmosphere to enable a much more precise landing location.[49][50] Iteration on the design continued into 2017. Larger and more robust grid fins, made from forged titanium and left unpainted, were first tested in June 2017, and has been used on all reusable Block 5 Falcon 9 first stages since May 2018.[51]
![](../I/Falcon_9_with_CRS-3_Dragon_in_SLC-40_hangar_(16855338881).jpg.webp)
- The rocket engine needs to be throttleable to achieve zero velocity at the same time the rocket reaches the ground. Even the lowest possible thrust of a single Merlin 1D engine exceeds the weight of the nearly empty Falcon 9 booster core, therefore the rocket cannot hover.[52][53][50]
- Terminal guidance and landing capability,[20] including a vehicle control system and a control system software algorithm to be able to land a rocket with the thrust-to-weight ratio of the vehicle greater than one,[54] with closed-loop thrust vector and throttle control[55][50]
- Navigation sensor suite for precision landing[47][56][50]
![](../I/Autonomous_Spaceport_Drone_Ship_-_Just_Read_the_Instructions_(16450469297).png.webp)
- A large floating landing platform for launches where the first stage does not have sufficient fuel to return to the launch site. As of 2022, SpaceX built three autonomous spaceport drone ships, one operating the West coast and two on the East coast of the United States.
- A thermal protection system to avoid damage to the first stage when re-entering the atmosphere.[57]
- Lightweight, deployable landing gear for the booster stage.[17][50] In May 2013, the design was shown to be a nested, telescoping piston on an A-frame. The total span of the four carbon fiber/aluminum extensible landing legs[58][59] is approximately 18 meters (60 ft), and weigh less than 2,100 kilograms (4,600 lb). Deployment system uses high-pressure Helium as the working fluid.[60][61] With Flight 25 it was announced that each landing leg contained a "crush core", to absorb the impact of landing for particularly hard landings.[62][63]
Economics of rocket reuse
In order to make the Falcon 9 reusable and return to the launch site, extra propellant and landing gear must be carried on the first stage, requiring around a 30 percent reduction of the maximum payload to orbit in comparison with the expendable Falcon 9.[64] Reflight of a previously used stage on a subsequent flight is dependent on the condition of the landed stage, and is a technique that has seen little use outside of the Space Shuttle's reusable solid rocket boosters.
Musk projected in 2015 that the reflight step of the program would be "straightforward," because of the multiple full duration firings of the engines that had been done on the ground, and the multiple engine restarts that had been demonstrated by that time, with no significant degradation seen.[65] In 2015, industry analysts continued to forecast problems that could prevent economic reuse because costs to refurbish and relaunch the stage were not yet demonstrated, and the economic case for reuse would necessarily be highly dependent on launching frequently.[66]
SpaceX is expected to significantly reduce the cost of access to space, and change the increasingly competitive market in space launch services.[26][67] Michael Belfiore wrote in Foreign Policy in 2013 that, at a published cost of US$56.5 million per launch to low Earth orbit, "Falcon 9 rockets are already the cheapest in the industry. Reusable Falcon 9s could drop the price by an order of magnitude, sparking more space-based enterprise, which in turn would drop the cost of access to space still further through economies of scale."[24] Even for military launches, which have a number of contractual requirements for additional launch services to be provided, SpaceX's price is under US$100 million.[68][69]
![](../I/Falcon_9_First_Stage_Reusability_Graphic.jpg.webp)
Space industry analyst Ajay Kothari has noted that SpaceX reusable technology could do for space transport "what jet engines did for air transportation sixty years ago when people never imagined that more than 500 million passengers would travel by airplanes every year and that the cost could be reduced to the level it is—all because of passenger volume and reliable reusability."[70] SpaceX said in January 2014 that if they are successful in developing the reusable technology, launch prices of around US$5 to 7 million for a reusable Falcon 9 were possible,[71] and following the successful first stage recovery in December 2015, Musk said that "the potential cost reduction over the long term is probably in excess of a factor of 100."[66]
As of March 2014 launch service providers who compete with SpaceX were not planning to develop similar technology or offer competing reusable launcher options. Neither ILS, which markets launches of the Russian Proton rocket; Arianespace; nor SeaLaunch were planning on developing and marketing reusable launch vehicle services. SpaceX was the only competitor that projected a sufficiently elastic market on the demand side to justify the costly development of reusable rocket technology and the expenditure of private capital to develop options for that theoretical market opportunity.[72]
In 2014 the Falcon 9 v1.1 rocket was designed with about 30 percent more capacity than its official payload specifications; the additional performance was reserved for SpaceX to perform first-stage re-entry and landing tests towards reusability while still achieving the specified orbital payload delivery for customers.[73]
In order to achieve the full economic benefit of the reusable technology, it is necessary that the reuse be both rapid and complete—without the long and costly refurbishment period or partially reusable design that plagued earlier attempts at reusable launch vehicles. SpaceX has been explicit that the "huge potential to open up space flight"[74] is dependent on achieving both complete and rapid reusability.[28][68] CEO Musk stated in 2014 that success with the technology development effort could reduce "the cost of spaceflight by a factor of 100"[75] because the cost of the propellant/oxidizer on the Falcon 9 is only 0.3 percent of the total cost of the vehicle.[76]
Separate from the market competition brought about by SpaceX lower launch prices and the potential future of even more radically lower launch prices if the technology can be completed successfully, Aviation Week said in 2014 that "SpaceX reusable launch work is an R&D model"—"The audacity of the concept and speed of the program’s progress make it an exemplar. ... [the] breakneck pace of development has been almost Apollo-like in its execution... [even while] success is far from guaranteed."[77]
On March 9, 2016, SpaceX President Gwynne Shotwell gave a more realistic appraisal of the potential savings of a reused launch now that attempts to reuse the second stage had been abandoned due to cost and weight issues. She said at US$1 million cost of refueling and US$3 million cost of refurbishing a used first stage could potentially allow a launch to be priced as low as US$40 million, a 30% saving. SpaceX biggest customer SES said it wants to be the first to ride a reused vehicle, however it wants a launch price of US$30 million or a 50% saving to offset the risk of pioneering the process.[78]
According to Elon Musk, almost every piece of the Falcon should be reused over 100 times. Heat shields and a few other items should be reused over 10 times before replacement.[79] In March 2017, SpaceX announced progress in their experiments to recover, and eventually reuse, the 6-million dollar payload fairing. On the SES-10 mission, one of the fairing halves performed a controlled atmospheric reentry and splashdown using thrusters and a steerable parachute; fairings are eventually slated to land on a floating "bouncy castle" structure.[80]
SpaceX began re-flight of previously launched booster stages in 2017. The first re-flight was accomplished in March 2017, nearly a year after the booster's maiden flight; the second was in June 2017, only five months after its maiden flight. Both were successful, and both insurers and launch service customers are readily supporting the newly emerging market in launch services provided by multiple-use boosters.[3]
In August 2020, Elon Musk tweeted that refurbishment and reuse of a booster is done for less than 10% the price of a new booster while the payload reduction is below 40%. According to his tweet SpaceX breaks even with a second flight per booster and saves money from the third flight on.[81] At that time Falcon 9 Block 5 had made 35 flights with 11 boosters.
Technical feasibility
Prior to the reusability program's success in December 2015, the return of an orbital launch system booster rocket had never been accomplished, and many questioned both technical and economic feasibility. And even after this success, the rapid reuse of a rocket has not been attempted. Developing a reusable rocket is extremely challenging due to the small percentage of a rocket's mass that can make it to orbit.[12][82] Typically, a rocket's payload is only about 3% of the mass of the rocket which is also roughly the amount of mass in fuel that is required for the vehicle's re-entry.[83]
Elon Musk said at the beginning of the program that he believed the return, vertical landing and recovery was possible because the SpaceX manufacturing methodologies result in a rocket efficiency exceeding the typical 3% margin. A SpaceX rocket operating in the reusable configuration has approximately 30% less payload lift capacity than the same rocket in an expendable configuration.[25]
Although the reusable launch system technology was developed and initially used for the first stages of the Falcon family of rockets[5] it is particularly well suited to the Falcon Heavy where the two outer cores separate from the rocket earlier in the flight, and are therefore moving more slowly at stage separation. For example, on Falcon 9 flight 20, the speed at separation was close to 6000 km/h[84] and this allowed a return to near the launch site. On flight 22, going to a more-energetic GTO orbit, the higher velocity at separation was between 8000 and 9000 km/h. At these faster speeds it is not possible to return the booster to near the launch site for a landing; if a landing is attempted it needs to be hundreds of kilometers downrange on an autonomous droneship.
Reuse also has an impact on risk estimates. While early customers of reused rockets asked for a lower price[85] a booster that has flown already has been demonstrated to work under realistic flight conditions. Some customers now prefer reused boosters over new boosters.[86]
Falcon 9 reusability development
In 2013 SpaceX was testing reusable technologies both for its first-stage booster launch vehicle designs (with three test vehicles : Grasshopper, F9R Dev1, and F9R Dev2) — and for its new reusable SpaceX Dragon 2 space capsule (with a low-altitude test vehicle called DragonFly).
SpaceX has publicly disclosed a multi-element, incremental test program for booster stages that includes four aspects:
- low-altitude (less than 760 m/2,500 ft[16][87]), low-velocity testing of its single-engine Grasshopper technology-demonstrator at its Texas test site
- low-altitude (less than 3,000 m/9,800 ft), low-velocity testing of a much larger, second-generation, three-engine test vehicle called F9R Dev1. The second generation vehicle includes extensible landing legs and will be tested at the Texas test site[88]
- high-altitude, mid-velocity testing was planned but cancelled in favor of post-mission re-entry tests of first-stage boosters. It would have used F9R Dev2 at a SpaceX leased facility at Spaceport America in New Mexico.
- high-altitude (91 km/300,000 ft[89]), very-high-velocity (approximately 2.0 km/s; 6,500 km/h; 4,100 mph; Mach 6[1]) ballistic reentry, controlled-deceleration and controlled-descent tests of post-mission (spent) Falcon 9 booster stages following a subset of Falcon 9 launches that began in 2013.
Eight low-altitude booster flight tests were made by Grasshopper in 2012 and 2013. The first booster return controlled-descent test from high-altitude was made in September 2013, with a second test in April,[26][29][90] a third test flight in July[91] and a fourth test in September 2014. All four test flights to date were intended to be over-water, simulated landings.[36] Five low-altitude booster flight tests of F9R Dev1 were flown during April–August 2014, before the vehicle self-destructed for safety reasons on the fifth flight.[92][93]
Flight test vehicles
![](../I/SpaceX_Grasshopper_rocket_midflight.png.webp)
SpaceX used a set of experimental technology-demonstrator, suborbital reusable launch vehicles (RLV) to begin flight testing their reusable booster technologies in 2012. Two versions of the prototype reusable test rockets were built—the 106-foot (32 m) tall Grasshopper (formerly designated as Grasshopper v1.0) and the 160-foot (49 m) tall Falcon 9 Reusable Development Vehicle, or F9R Dev1—formerly known as Grasshopper v1.1[74]—as well as a capsule prototype for testing propulsive landings of the Dragon crew and cargo capsule for the Falcon 9—DragonFly.[74] Grasshopper was built in 2011–2012 for low-altitude, low-velocity hover testing that began in September 2012 and concluded in October 2013 after eight test flights.[16][17][74] The second prototype vehicle design, F9R Dev1, was built on the much larger Falcon 9 v1.1 booster stage was used to further extend the low-altitude flight testing envelope on a vehicle that better matched the actual flight hardware, and made five test flights in 2014.[74][94][95] The low-altitude, low-speed flights of the test vehicle rockets and capsule were conducted at the SpaceX Rocket Test Facility in McGregor, Texas[16][17][74]
SpaceX indicated in November 2018 that they considered testing a heavily modified Falcon 9 second stage that would look like a "mini-BFR Ship" and be used for atmospheric reentry testing of a number of technologies needed for the full-scale spaceship, including an ultra-light heat shield and high-Mach control surfaces,[96][97] but two weeks later, Musk dismissed the approach in favor of using a full-diameter BFR instead.[98]
Grasshopper
Grasshopper, the company's first VTVL test vehicle, consisted of a Falcon 9 v1.0 first-stage tank, a single Merlin-1D engine, and four permanently attached steel landing legs. It stood 106 feet (32 m) tall.[17] SpaceX built a 0.5-acre (0.20 ha) concrete launch facility at its Rocket Development and Test Facility in McGregor, Texas to support the Grasshopper flight test program.[99] Grasshopper was also known as Grasshopper version 1.0, or Grasshopper v1.0, prior to 2014 during the time the followon Grasshopper-class test vehicles were being built.
In addition to three test flights in 2012, five additional tests were successfully flown by the end of October 2013—including the fourth test overall in March 2013—in which Grasshopper doubled its highest leap to rise to 80.1 meters (263 ft) with a 34-second flight.[100] In the seventh test, in August 2013, the vehicle flew to 250 meters (820 ft) during a 60-second flight and executed a 100-meter (330 ft) lateral maneuver before returning to the pad.[101] Grasshopper made its eighth and final test flight on October 7, 2013, flying to 744 meters (2,441 ft) before making its eighth successful landing.[102] The Grasshopper test vehicle is now retired.[103]
Falcon 9 Reusable Development Vehicle
As early as October 2012, SpaceX discussed development of a second-generation Grasshopper test vehicle, which was to have lighter landing legs that fold up on the side of the rocket, a different engine bay, and would be nearly 50% longer than the first Grasshopper vehicle.[95] In March 2013, SpaceX announced that the larger Grasshopper-class suborbital flight vehicle would be constructed out of the Falcon 9 v1.1 first-stage tank that was used for qualification testing at the SpaceX Rocket Development and Test Facility in early 2013. It was rebuilt as the F9R Dev1 with extensible landing legs. Five test flights occurred in 2014.[74]
The second VTVL flight test vehicle—F9R Dev1, built on the much longer Falcon 9 v1.1 first-stage tank, with retractable landing legs—made its first test flight on April 17, 2014.[74][92] F9R Dev1 was used for low-altitude test flights in the McGregor, Texas area—projected maximum altitude below 3,000 meters (10,000 ft)[74]—with a total of five test flights, all made during 2014. This vehicle self-destructed as a safety measure during its fifth test flight on August 22, 2014.[104]
By April 2014, a third flight test vehicle—F9R Dev2—was being built and was planned to be flown at the high-altitude test range available at Spaceport America in New Mexico where it was expected to be flown at altitudes up to 91,000 meters (300,000 ft)-plus.[74] It was never flown as SpaceX moved the high-altitude testing program to its controlled-descent testing of used boosters following their use on a paid orbital launch and ascent.
DragonFly
DragonFly was a prototype test article for a propulsively landed version of the SpaceX Dragon capsule, a suborbital reusable launch vehicle (RLV), intended for low-altitude flight testing. As of May 2014 it was planned to undergo a test program in Texas at the McGregor Rocket Test Facility, during 2014–2015.[32][105]
The DragonFly test vehicle is powered by eight SuperDraco engines, arranged in a redundant pattern to support fault-tolerance in the propulsion system design.[106] SuperDracos utilize a storable propellant mixture of monomethyl hydrazine (MMH) fuel and nitrogen tetroxide oxidizer (NTO), the same propellants used in the much smaller Draco thrusters used for attitude control and maneuvering on the first-generation Dragon spacecraft.[105] While SuperDraco engines are capable of 73,000 newtons (16,400 lbf) of thrust, during use on DragonFly flight test vehicle each will be throttled to less than 68,170 newtons (15,325 lbf) to maintain vehicle stability.[105]
A test flight program of thirty flights was proposed in 2013–2014, including two propulsive assist (parachutes plus thrusters) and two propulsive landing (no parachutes) on flights dropped from a helicopter at an altitude of approximately 10,000 feet (3,000 m). The other 26 test flights were projected to take off from a pad: eight to be propulsive assist hops (landing with parachutes plus thrusters) and 18 to be full propulsive hops, similar to the Grasshopper and F9R Dev booster stage test flights.[105][106] As of 2014, the DragonFly test program was not expected to start until after the completion of the F9R Dev1 booster testing at the McGregor facility.[106]
Falcon 9 booster post-mission flight tests
![](../I/CRS-6_first_stage_booster_landing_attempt.jpg.webp)
In an arrangement highly unusual for launch vehicles, SpaceX began in 2013 using some first stages of the Falcon 9 v1.1 rockets for propulsive-return controlled-descent flight tests after they completed the boost phase of an orbital flight. Since the advent of spaceflight in 1957, launch vehicle boosters would ordinarily just be discarded after setting their payloads on their way. The over-water tests started by SpaceX took place in the Pacific and Atlantic oceans south of Vandenberg Air Force Base and east of Cape Canaveral Air Force Station. The first flight test occurred on September 29, 2013, after the second stage with the CASSIOPE and nanosat payloads separated from the booster. These descent and simulated landing tests continued over the next two years, with the second flight test taking place on April 18, 2014,[26][29][90] two more test in 2014, and four subsequent tests conducted in 2015.[107] SpaceX continued to make iterative and incremental changes to the booster design, as well as the specific reusable technologies, descent profile and propellant margins, on some 2016-2018 Falcon 9 and Falcon Heavy flights to tweak the design and operational parameters. Many of these descent and landing tests were tested on active orbital spaceflight missions for SpaceX customers as the booster reentered the atmosphere and attempted recoverable landings.
Re-entry and controlled descent
Following analysis of the flight test data from the first booster-controlled descent in September 2013, SpaceX announced it had successfully tested a large amount of new technology on the flight, and that coupled with the technology advancements made on the Grasshopper low-altitude landing demonstrator, they were ready to test a full recovery of the booster stage. The first flight test was successful; SpaceX said it was "able to successfully transition from vacuum through hypersonic, through supersonic, through transonic, and light the engines all the way and control the stage all the way through [the atmosphere]".[25] Musk said, "the next attempt to recovery [sic] the Falcon 9 first stage will be on the fourth flight of the upgraded rocket. This would be [the] third commercial Dragon cargo flight to ISS."[27]
This second flight test took place during the April 2014 Dragon flight to the ISS. SpaceX attached landing legs to the first stage, decelerated it over the ocean and attempted a simulated landing over the water, following the ignition of the second stage on the third cargo resupply mission contracted to NASA. The first stage was successfully slowed down enough for a soft landing over the Atlantic Ocean.[29] SpaceX announced in February 2014 the intent to continue the tests to land the first-stage booster in the ocean until precision control from hypersonic all the way through subsonic regimes has been proven.[90] Five additional controlled-descent tests were conducted in the remainder of 2014 through April 2015, including two attempts to land on a floating landing platform—a SpaceX-built Autonomous Spaceport Drone Ship—on the Atlantic Ocean east of the launch site, both of which brought the vehicle to the landing platform, but neither of which resulted in a successful landing.
First landing on ground pad
![](../I/ORBCOMM-2_First-Stage_Landing_(23271687254).jpg.webp)
During the 2015 launch hiatus, SpaceX requested regulatory approval from the FAA to attempt returning their next flight to Cape Canaveral instead of targeting a floating platform in the ocean. The goal was to land the booster vertically at the leased Landing Zone 1 facility—the former Launch Complex 13 where SpaceX had recently built a large rocket landing pad.[108] The FAA approved the safety plan for the ground landing on December 18, 2015.[109] The first stage landed successfully on target at 20:38 local time on December 21 (01:38 UTC on December 22).[110][107]
First stage booster B1019 never flew again after the flight.[111] Rather, the rocket was moved a few miles north to the SpaceX hangar facilities at Launch pad 39A, recently refurbished by SpaceX at the adjacent Kennedy Space Center, where it was inspected before being used on January 15, 2016, to conduct a static fire test on its original launchpad, Launch Complex 40.[112] This test aimed to assess the health of the recovered booster and the capability of this rocket design to fly repeatedly in the future.[113][107] The tests delivered good overall results except for one of the outer engines experiencing thrust fluctuations.[113] Elon Musk reported that this may have been due to debris ingestion.[114] The booster was then retired to the SpaceX facility in Hawthorne, California.
![](../I/First_stage_of_Jason-3_rocket_(24423604506).jpg.webp)
Landing attempts on drone ships
Falcon 9 Flight 21 launched the Jason-3 satellite on January 17, 2016, and attempted to land on the floating platform Just Read the Instructions,[115] located for the first time about 200 miles (320 km) out in the Pacific Ocean. Approximately 9 minutes into the flight, the live video feed from the drone ship went down due to the losing its lock on the uplink satellite. The vehicle landed smoothly onto the vessel but one of the four landing legs failed to lock properly, reportedly due to ice from the heavy pre-launch fog preventing a lockout collet from latching.[116] Consequently the booster fell over shortly after touchdown and was destroyed in a deflagration upon impact with the pad.[117][118]
Flight 22 was carrying a heavy payload of 5,271 kilograms (12,000 lb) to geostationary transfer orbit (GTO). This was heavier than previously advertised maximum lift capacity to GTO being made possible by going slightly subsynchronous. Following delays caused by failure of Flight 19, SpaceX agreed to provide extra thrust to the SES-9 satellite to take it supersynchronous.[119] As a result of these factors, there was little propellant left to execute a full reentry and landing test with normal margins. Consequently the Falcon 9 first stage followed a ballistic trajectory after separation and re-entered the atmosphere at high velocity, making it less likely to land successfully.[120][119] The atmospheric re-entry and controlled descent were successful despite the higher aerodynamical constraints on the first stage due to extra speed. However the rocket was moving too fast and was destroyed when it collided with the drone ship. SpaceX collected valuable data on the extended flight envelope required to recover boosters from GTO missions.
First landings at sea
![](../I/CRS-8_(26239020092).jpg.webp)
Starting in January 2015, SpaceX positioned stable floating platforms a few hundred miles off the coast along the rocket trajectory; those transformed barges were called autonomous spaceport drone ships.[121] On April 8, 2016, Falcon 9 Flight 23, the third flight of the full-thrust version, delivered the SpaceX CRS-8 cargo on its way to the International Space Station while the first stage conducted a boostback and re-entry maneuver over the Atlantic ocean. Nine minutes after liftoff, the booster landed vertically on the drone ship Of Course I Still Love You, 300 km from the Florida coastline, achieving a long-sought-after milestone for the SpaceX reusability development program.[122]
A second successful drone ship landing occurred on May 6, 2016, with the next flight which launched JCSAT-14 to GTO. This second landing at sea was more difficult than the previous one because the booster at separation was traveling about 8,350 km/h (5,190 mph) compared to 6,650 km/h (4,130 mph) on the CRS-8 launch to low Earth orbit.[123] Pursuing their experiments to test the limits of the flight envelope, SpaceX opted for a shorter landing burn with three engines instead of the single-engine burns seen in earlier attempts; this approach consumes less fuel by leaving the stage in free fall as long as possible and decelerating more sharply, thereby minimizing the amount of energy expended to counter gravity.[124] Elon Musk indicated this first stage may not be flown again instead being used as a life leader for ground tests to confirm others are good.[125]
A third successful landing followed on 27 May, again following deceleration from the high speed required for a GTO launch. The landing crushed a "crush core" in one leg, leading to a notable tilt to the stage as it stood on the drone ship.[62]
Routine procedure
Over the subsequent missions, landing of the first stage gradually became a routine procedure, and since January 2017 SpaceX ceased to refer to their landing attempts as "experimental". Low-energy missions to the ISS fly back to the launch site and land at LZ-1, whereas more demanding satellite missions land on drone ships a few hundred miles downrange. Occasional missions with heavy payloads, such as EchoStar 23, do not attempt to land, flying in expendable configuration without fins and legs.
During 2016 and 2017, SpaceX has recovered a number of first stages to both land and drone ships, helping them optimize the procedures needed to re-use the boosters rapidly. In January 2016 Elon Musk estimated the likelihood of success at 70 percent for all landing attempts in 2016, hopefully rising to 90 percent in 2017; he also cautioned that we should expect "a few more RUDs" (Rapid Unscheduled Disassembly, Musk's euphemism to denote destruction of the vehicle on impact).[126] Musk's prediction was vindicated, as 5 out of 8 flown boosters (63%) were recovered in 2016, and 14 out of 14 (100%) in 2017. Three GTO missions for heavy payloads (EchoStar 23 in March 2017, Inmarsat-5 F4 in May 2017 and Intelsat 35e in July 2017) were flown in an expendable configuration, not equipped for landing. One booster which could have been recovered was intentionally flown without legs and left to sink after a soft touchdown in the ocean (booster B1036 for the Iridium NEXT 31–40 mission in December 2017).
First-stage reuse
As of 6 August 2018, SpaceX had recovered 21 first-stage boosters from previous missions, of which six were recovered twice, yielding a total 27 landings. In 2017, SpaceX flew a total of 5 missions out of 20 with re-used boosters (25%). In total, 14 boosters have been re-flown as of August 2018.
On July 28, 2016, the first stage from the JCSAT-2B mission was successfully test-fired for a full duration at the SpaceX McGregor facility.[127] The first reuse attempt occurred on 30 March 2017[128] with the launch of SES-10,[129] resulting in a successful flight and second landing of the B1021 first stage recovered from the CRS-8 mission of April 2016.[130] Another reflight succeeded in June 2017 with BulgariaSat-1 riding the B1029 booster from the January 2017 Iridium NEXT mission.[131] Booster B1031 flew the CRS-10 mission to the ISS in February 2017 and helped loft communications satellite SES-11 to geostationary orbit in October 2017. Boosters B1035 and B1036 were flown twice each for the same customer, B1035 for NASA missions CRS-11 and CRS-13 in June and December 2017, and B1036 for two batches of 10 Iridium NEXT satellites, also in June and December 2017. B1032 was re-used for GovSat-1 in January 2018 after NROL-76 in May 2017.
SpaceX spent four months refurbishing the first booster to be re-used, B1021, and launched it again after approximately one year.[132] The second booster to be flown again, B1029, was refurbished in "only a couple of months"[3] and re-launched after five months.[131] Elon Musk has stated a goal to turn around a first stage within 24 hours.[133] Musk remains convinced that this long-term goal can be met by SpaceX rocket technology,[134] but has not stated that the goal would be achieved with the Falcon 9 design.
Boosters B1019 and B1021 were retired and put on display. B1029 was also retired after the BulgariaSat-1 mission. B1023, B1025, B1031 and B1035 were recovered a second time, while B1032 and B1036 were deliberately sunk at sea after a soft ocean touchdown.[135]
By mid-2019, having reflown any single booster only three times to date, SpaceX indicated that they plan to use a single booster at least five times by the end of 2019.[136] No booster achieved this, but B1048 flew four times and two more (B1046 and B1049) made a fourth flight in January 2020. In March 2020, SpaceX first flew a booster (B1048) for the fifth time.[137]
Falcon Heavy reusability
Falcon Heavy test flight had no contracted customer, and in order to limit the cost on such a test flight, SpaceX targeted to have reused side-boosters. Boosters B1023 and B1025 that had been flown as Falcon 9 configuration, were reconfigured and used as side boosters on the first flight of Falcon Heavy in February 2018, and then both landed side-by-side at almost the same time on the ground pads. Later Falcon Heavy flights used either new boosters, or side-boosters previously flown on a Falcon Heavy. SpaceX has been unable to recover the central core in any of the three Falcon Heavy, but managed to recover all the six-side boosters.[138]
Block 5 boosters
With a streak of 19 successful recovery attempts of the first stage from 2016 through to early 2018, SpaceX has focused on rapid reusability of first stage boosters. Block 3 and Block 4 proved economically feasible to be flown twice, as 11 such boosters have been reflown in 2017 and 2018. Block 5 has been designed with multiple reuses in mind, up to 10 reuses with minimal inspection and up to 100 uses with refurbishment.[139] New aggressive reentry profiles were experimented with expendable Block 3 and Block 4 boosters in early 2018, to test out the limitations on the range of recoverable launch margins that are potential for future Block 5.[140] On 9 May 2021, B1051 became the first booster to be launched and landed for the tenth time, achieving one of SpaceX's milestone goals for reuse.[141]
Fairing reuse
Payload fairings have traditionally been expendable, where they have either burned up in the atmosphere or were destroyed upon impacting the ocean. As early as mid-2015, Musk hinted that SpaceX might be working on fairing reusability, following the discovery of wreckage of an unidentified Falcon 9 launch vehicle section off the coast of The Bahamas, and was subsequently confirmed by SpaceX to be a component of a payload fairing that had washed ashore.[142] By April 2016, SpaceX had publicly announced Falcon 9 fairing recovery as an objective.[42] The cost of the fairing is about $6 million per launch, which accounts for approximately ten percent of the overall launch costs.[143] Musk said in 2017: "Imagine if you had $6 million in cash in a pallet flying through the air, and it was going to smash into the ocean. Would you try to recover that? Yes, yes you would."[144]
In March 2017, as part of the SES-10 mission, SpaceX for the first time performed a controlled landing of the payload fairing and successfully recovered a fairing half, aided by attitude-control thrusters and a steerable parachute, helping it glide towards a gentle touchdown on water.[2][42] The company announced intent to land the fairings eventually on a dry flexible structure, jokingly described by Musk as a "floating bouncy-castle", with the aim of full fairing reuse.[80] With successive tests and refinements on several flights, intact fairing recovery was stated as an objective for 2017, with reflight of a recovered fairing planned in 2018.[43]
The "bouncy castle" meme was in fact a net strung between large arms of a fast platform supply vessel named Mr. Steven (now GO Ms. Tree). The recovery vessel is equipped with dynamic positioning systems, and was tested after the launch of the Paz satellite from Vandenberg Air Force Base in 2017.[145][146] This mission was also the first to use a version 2 fairing, explicitly designed to "improve survivability for post-launch recovery attempts, and to be reusable on future missions".[147] This recovery attempt was not fully successful; the fairing missed the boat by a few hundred meters but landed intact in the water[148] before being recovered and taken back to port.[146] As of August 2018, all four attempts by SpaceX to land a fairing on a recovery ship had failed, despite fitting Mr. Steven with larger nets before the July 2018 attempt.[149][150]
In October 2018, at least two fairing recovery tests were performed, involving Mr. Steven and a helicopter, which would drop a fairing half from the height of about 3300 meters. The outcome of the tests was unclear.[151]
In April 2019, during the second Falcon Heavy mission, recovery boat Go Searcher fished the fairing halves out of the sea and it was announced the fairings would be used on a Starlink mission.[152] These fairings were reused in a Starlink mission on 11 November 2019.[153]
In June 2019, following the third Falcon Heavy launch, the first successful fairing catch was made. Images posted to Twitter hours after launch showed one half of the fairing nestled in the net of the recovery vessel GO Ms. Tree.[154]
By late 2020, payload fairings were being regularly recovered by SpaceX, with SpaceX dispatching two custom-modified recovery ships—Ms. Tree and Ms. Chief—to collect the fairings on most launches from their Florida launch site. By this time, SpaceX was also regularly reflying recovered fairings on launches, usually on their own flights where Starlink satellites are the primary or only payload. As of August 2020 however, successful net landings were not yet routine, with less than half of the fairings of the previous three months being caught in the nets, but most still recovered anyway after a soft landing in the ocean.
By April 2021, SpaceX had abandoned the experimental program to attempt recovery of dry payload fairings under parachute descent in a net on a fast ship. SpaceX determined to operationalize "wet recovery" of fairings on future Falcon 9 flights, having found that they can clean, refurbish, and reuse such fairings more economically.[155] SpaceX released Miss Tree and Miss Chief from their contracts and purchased two ships for fairing recovery operations as well as for towing and supporting droneships on the east coast. These two ships were named in honour of Demo-2 astronauts Doug Hurley and Bob Behnken as Doug[156] and Bob. The earlier names of the ships Bob and Doug were Ella G and Ingrid respectively. Currently, Doug is operating at Port Canaveral while Bob is at Tampa undergoing construction.
By 26 May 2021, SpaceX had launched 40 flights that reflew at least one previously-flown fairing half, and one fairing had flown on five different flights, having been recovered and cleaned four previous times.[144]
Second-stage reuse
Despite early public statements that SpaceX would endeavor to make the Falcon 9 second-stage reusable as well, by late 2014, they determined that the mass needed for a re-entry heat shield, landing engines, and other equipment to support recovery of the second stage as well as the diversion of development resources from other company objectives was at that time prohibitive, and indefinitely suspended their second-stage reusability plans for the Falcon rockets.[157][158] However, in July 2017[43] they indicated that they might do experimental tests on recovering one or more second-stages in order to learn more about reusability to inform their Starship development process,[159] and in May 2018 provided additional details about how they might carry out some of that testing.[160]
The Starship is planned to replace all existing SpaceX launch and space vehicles after the mid-2020s: Falcon 9, Falcon Heavy and the Dragon spacecraft, aimed initially at the Earth-orbit launch market but with capability to support long-duration spaceflight in the cislunar and Mars mission environments.[161] Both stages will be fully reusable. The integrated second-stage-with-spaceship design has not been used in previous launch vehicles.[161]
Reuse of Dragon capsules
SpaceX's Dragon capsules have been gradually improved for reuse. Structural elements and internal components are being refurbished between flights, while the heat shield is replaced for each new mission. The last newly built Dragon cargo capsule first flew in July 2017; all subsequent ISS resupply missions were conducted with refurbished capsules,[162] some capsules made a third flight.[163][164] Dragon's trunk section cannot be reused, as it is designed to burn up in the atmosphere after completing its mission.[165]
SpaceX Dragon 2 is planned to be reused as well. Initially it was planned to use new capsules for all crewed NASA missions[166] but experience with the demonstration missions lead to NASA and SpaceX agreeing on reuse starting from Crew-2.[167][168]
Operational flow
In the first year of successful stage return from the experimental test flights, SpaceX performed ad hoc and flight-specific evaluation and component testing on each successfully landed stage. Stages were processed and initially evaluated in either launch hangars, or for Cape Canaveral landings, in the new hangar SpaceX recently completed at Kennedy Space Center Launch Complex 39. Returned rocket parts have also been transported to SpaceX Hawthorne and SpaceX McGregor for engineering evaluation and testing.
In February 2017, after eight rocket cores had successfully landed — seven of them having launched from Cape Canaveral — SpaceX announced plans to expand their physical facilities to process and refurbish rockets. They will do so in both leased space and in a new building to be built in Port Canaveral, Florida, near the location where the Atlantic Autonomous Spaceport Drone Ship is berthed, and where stages that land on the east-coast droneship are now removed from the ship.[169]
Starship reusability development
The goal of Starship launch system is to be a fully reusable orbital launch and reentry vehicle.[170] The Starship launch system consists of two stages: a Super Heavy booster and a Starship spacecraft;[171] both have a body made from SAE 304L stainless steel[172] and are designed to hold liquid oxygen and liquid methane. Super Heavy and then Starship will boost the rocket up to orbital speed, after which both of them will land and can be used again. Starship can send more than 100 metric tons (220,000 lb) to low Earth orbit;[173] higher Earth and other orbits are accessible after being refueled by tanker Starships. Future planned Starship variants will be able to land on the Moon and Mars.[174] Starship's design has influenced other launch vehicles, such as the Terran R's full reusability capability.[175]
Design history
![](../I/BFR_in_flight_(cropped)-2018_version.png.webp)
The first reference by SpaceX of a rocket concept with Starship lifting capabilities was in 2005. In a student conference, Musk briefly mentioned a theoretical heavy‑lift launch vehicle code-named BFR, later known as the Falcon XX.[176] It would be powered by a larger version of the Merlin engine, called Merlin 2, and feature a lifting capability of 140 metric tons (310,000 lb) to low Earth orbit.[177] In 2012, in a public discussion about a conceptual Mars colonization program, Musk described the Mars Colonial Transporter. He envisioned it as a reusable super heavy-lift launch vehicle that could deliver approximately 150 to 200 metric tons (330,000 to 440,000 lb) to low Earth orbit. The Mars Colonial Transporter might be powered by Raptors, consuming liquid methane and liquid oxygen.[178]
In September 2016, at the 67th International Astronautical Congress, Musk announced the Interplanetary Transport System (ITS), a conceptual reusable rocket conceived to launch humans to Mars and other destinations in the Solar System. The ITS was to be 122 m (400 ft) tall, 12 m (39 ft) wide, and capable of lifting 300 metric tons (660,000 lb) to low Earth orbit.[179] Both stages were to be made from carbon composites. The first stage or booster was to be powered by 42 Raptors, and the second stage by nine Raptors.[180] Once refueled while in Earth orbit, the spacecraft could accelerate to Mars.[181] When an Interplanetary Spaceship enters the atmosphere, it cools itself via transpiration and controls the spacecraft's descent by moving its delta wings and split flaps.[182] At the following Congress, Musk announced a replacement rocket called the Big Falcon Rocket or informally Big Fucking Rocket. The Big Falcon Rocket is 106 m (348 ft) tall and 9 m (30 ft) wide.[183] In that conference, he talked about a possible suborbital transportation feature and termed it Earth to Earth.[184]
In November 2018, the present names were first used: Super Heavy for the booster, Starship for the spacecraft, and Starship system or just Starship for the whole vehicle.[185] Around that time, Musk announced a redesigned spacecraft concept with three aft flaps and two forward flaps.[186] In January 2019, Musk announced that Starship would be made from stainless steel and stated that this might be stronger than an equivalent carbon composite in a wide range of temperatures.[187] In March, Musk tweeted that SpaceX opted for a heat shield composed of hexagonal ceramic tiles instead of transpiration.[188] In October, the Starship spacecraft's engine configuration was changed to three Raptors optimized for atmospheric pressure and three optimized for space.[189] The number of rear fins was reduced from three to two and placed at the heat shield's edges.[190]
Testing
![](../I/SpaceX_Starship_SN8_launch_as_viewed_from_South_Padre_Island.jpg.webp)
On 27 August 2019, a simplified test article named Starhopper hopped 150 m (490 ft) high.[191] Unveiled in a SpaceX event in September 2019, Starship Mk1 (Mark 1) was the first full‑scale Starship test article to be built. The Mk2 in Florida was constructed five months later.[192] Neither flew: Mk1 was destroyed during a cryogenic proof test and Mk2 was scrapped.[193] In early 2020, SpaceX changed Mk3's name to SN1 (serial number 1).[194] During a cryogenic proof test on 28 February 2021, a fault in SN1's bottom tank caused it to crumble. On 8 March 2020, SN2 stripped-down test tank completed its only cryogenic proof test.[195] On 3 April 2020, during SN3's cryogenic proof test, a valve leaked the liquid nitrogen inside its lower tank, causing the vessel to depressurize and collapse.[196] After SN4's fifth successful static fire test on 29 May 2020, the quick disconnect fuel line caused it to explode.[197] On 15 June 2020, Musk tweeted that new prototypes would be made from SAE 304L instead of 301 stainless steel.[172] On 4 August 2020, SN5 completed a 150 m (490 ft) hop using a single Raptor, the first full-scale test article to complete a flight test intact.[198] On 24 August 2020, SN6 replicated SN5's flight path successfully.[199] SN7 was not completed, but as of October 2021, its tanks were salvaged for various experiments.[200]
SN8 was the first complete test article.[201] In October and November 2020, SN8 underwent four static fire tests; the first, second, and fourth were successful, but the third caused an engine shutdown. According to Musk, the force from the engine destroyed parts of the launch pad sending some pieces of it into the engine.[202] On 9 December 2020, SN8 performed the first flight by a Starship, reaching an altitude of 12.5 km (7.8 mi). During landing, its methane header tank did not provide sufficient fuel to the Raptors, reducing thrust from one engine. The test article exploded on impact.[203] On 2 February 2021, SN9 flew 10 km (6.2 mi) high.[204] While descending, one of its engines did not function and burst on landing at an angle.[205] On 3 March 2021, SN10 repeated SN9's flight path, then hard landed and destroyed itself in an explosion 8 minutes later.[206]
The first Super Heavy booster named BN1 (booster number 1) finished construction on 8 March 2021, but it had not received engines.[207] On 30 March 2021, SN11 exploded in midair without a confirmed explanation because of the dense fog at the launch site.[208] A possible explanation is that an engine might have burned the test article's avionics and could have caused a hard start on the engine's turbopump.[209] After the launch, SpaceX skipped SN12, SN13, SN14, and BN2, and incorporated obsolete test articles' improvements to SN15 instead.[210] On 5 May 2021, the test article flew the same flight path as previous test articles and soft landed successfully.[211][212] On 20 July 2021, BN3 fired its engines for the only time.[213] As of October 2021, SN15, SN16, and BN3 had been retired and displayed.[211][214]
As of October 2021, skipping over SN16, SN17, SN18, and SN19, SN20 along with BN4[lower-alpha 1] are targeted to an orbital flight scheduled for late 2021. However, a NASA public document that outlines NASA's plan to observe Starship's reentry inferred that the launch might happen near March 2022.[170] However, the article did not specify that the observed flight would be the first test flight of the Starship, so an approximate launch date is still unknown. The Federal Aviation Administration (FAA) has not approved the environmental impact statement draft released on 19 September 2021.[216][217] BN4 is expected to separate about three minutes into the orbital flight and splashdown in the Gulf of Mexico, approximately 30 km (19 mi) from the shoreline. The rocket's SN20 second stage ground track will then traverse the middle of the Straits of Florida between Key West and Cuba, a range safety consideration to assure any debris from a malfunction falls away from populated areas. Once over the Atlantic Ocean, SN20 is then expected to accelerate close to orbital speed and splashdown around ninety minutes later 100 km (60 mi) northwest of Kauai, Hawaii.[218][219]
- Pictures of Starship test articles
- Starship Mk1's nose cone near construction tents
- Starhopper in construction
- A crane lifting Starship SN5
- Starship SN7's tank
- Starship SN9 on the launchpad
- A worker is examining Starship SN20's ceramic tiles
See also
- New Shepard, a sub-orbital VTVL system
- Grasshopper (rocket)
Notes
- Around August 2021, SpaceX used an alternate "Starship X" and "Booster X" naming scheme where X is the serial number. They are often abbreviated to "S" and "B", followed by the prototype's number. Sometimes, "Starship X" is abbreviated to "Ship X".[215]
References
- Simberg, Rand (February 8, 2012). "Elon Musk on SpaceX's Reusable Rocket Plans". Popular Mechanics. Archived from the original on October 6, 2014. Retrieved February 7, 2012.
- Henry, Caleb (March 30, 2017). "SpaceX demonstrates reusability". SpaceNews. Archived from the original on May 19, 2019. Retrieved September 13, 2017.
- de Selding, Peter B. (June 26, 2017). "SpaceX cuts flight-to-reflight time for Falcon 9 first stage". Space Intel Report. Archived from the original on November 9, 2019. Retrieved June 27, 2017.
- Sesnic, Trevor; Fletcher, Colin; Kanayama, Lee (May 8, 2021). "SpaceX flies historic 10th mission of a Falcon 9 as Starlink constellation expands". NASASpaceFlight.com. Archived from the original on May 16, 2021. Retrieved May 19, 2021.
- Foust, Jeff (October 25, 2014). "Next Falcon 9 Launch Could See First-stage Platform Landing". SpaceNews. Archived from the original on October 25, 2014. Retrieved October 25, 2014.
- Bergin, Chris (September 27, 2016). "SpaceX reveals ITS Mars game changer via colonization plan". NASASpaceFlight.com. Archived from the original on July 13, 2019. Retrieved October 16, 2016.
- Belluscio, Alejandro G. (March 7, 2014). "SpaceX advances drive for Mars rocket via Raptor power". NASAspaceflight.com. Archived from the original on September 11, 2015. Retrieved April 3, 2014.
- "SpaceX Not Planning to Upgrade Falcon 9 Second Stage". November 17, 2018. Archived from the original on August 23, 2019. Retrieved August 23, 2019.
- Musk, Elon (March 1, 2018). "Making Life Multi-Planetary". New Space. 6 (1): 2–11. Bibcode:2018NewSp...6....2M. doi:10.1089/space.2018.29013.emu.
- Graham, William (March 30, 2017). "SpaceX conducts historic Falcon 9 re-flight with SES-10 – Lands booster again". NASASpaceFlight.com. Archived from the original on May 17, 2017. Retrieved May 27, 2017.
'The earliest Falcon 9 launches carried parachutes which were to have been used to recover the first stage. However, this was abandoned due to the stage disintegrating during reentry, before the parachutes could be deployed. Instead, SpaceX began to investigate using the stage’s engines to make a powered descent and landing. Alongside this, an improved Falcon 9 vehicle, the Falcon 9 v1.1, was developed.'
- SpaceX Chief Details Reusable Rocket. Washington Post. Associated Press. September 29, 2011. Retrieved April 9, 2016.
- Wall, Mike (September 30, 2011). "SpaceX Unveils Plan for World's First Fully Reusable Rocket". Space.com. Archived from the original on October 10, 2011. Retrieved October 11, 2011.
- "Falcon 9 Return to Launch Site". SpaceX.com. Archived from the original (video) on October 11, 2011.
- Mark Hamrick, Elon Musk (September 29, 2011). National Press Club: The Future of Human Spaceflight. NPC video repository (video). National Press Club.
(@18:15 It is a very tough engineering problem—and it wasn't something that I thought, wasn't sure it could be solved for a while. But then, just relatively recently, in the last 12 months or so, I've come to the conclusion that it can be solved. And SpaceX is going to try to do it. Now, we could fail. I am not saying we are certain of success here, but we are going to try to do it. And we have a design that, on paper, doing the calculations, doing the simulations, it does work. Now we need to make sure that those simulations and reality agree, because generally when they don't, reality wins. So that's to be determined.)
- Boyle, Alan (December 24, 2012). "SpaceX launches its Grasshopper rocket on 12-story-high hop in Texas". NBC News / Cosmic Log. Archived from the original on March 3, 2016. Retrieved December 25, 2012.
- "Draft Environmental Assessment for Issuing an Experimental Permit to SpaceX for Operation of the Grasshopper Vehicle at the McGregor Test Site, Texas" (PDF). Federal Aviation Administration. September 22, 2011. Archived (PDF) from the original on January 12, 2013. Retrieved November 21, 2013.
- Mohney, Doug (September 26, 2011). "SpaceX Plans to Test Reusable Suborbital VTVL Rocket in Texas". Satellite Spotlight. Archived from the original on August 4, 2016. Retrieved November 21, 2013.
- "NASA Finishes Wind-tunnel Testing of Falcon 9 1st Stage". Space News. May 28, 2012. Retrieved June 26, 2012.
- Coppinger, Rod (November 23, 2012). "Huge Mars Colony Eyed by SpaceX Founder Elon Musk". Space.com. Archived from the original on June 28, 2013. Retrieved November 25, 2012.
much bigger [than Falcon 9], but I don’t think we’re quite ready to state the payload. We’ll speak about that next year.
- Foust, Jeff (March 9, 2013). "More on Grasshopper's "Johnny Cash hover slam" test". NewSpace Journal. Archived from the original on May 15, 2013. Retrieved May 2, 2013.
- Messier, Doug (March 28, 2013). "Dragon Post-Mission Press Conference Notes". Parabolic Arc. Archived from the original on May 31, 2013. Retrieved March 30, 2013.
Q. What is strategy on booster recover? Musk: Initial recovery test will be a water landing. First stage continue in ballistic arc and execute a velocity reduction burn before it enters atmosphere to lessen impact. Right before splashdown, will light up the engine again. Emphasizes that we don’t expect success in the first several attempts. Hopefully next year with more experience and data, we should be able to return the first stage to the launch site and do a propulsion landing on land using legs. Q. Is there a flight identified for return to launch site of the booster? Musk: No. Will probably be the middle of next year.
- Nield, George C. (April 2013). Draft Environmental Impact Statement: SpaceX Texas Launch Site (PDF) (Report). Vol. 1. Federal Aviation Administration / Office of Commercial Space Transportation. Archived from the original on December 7, 2013.
- @elonmusk (April 28, 2013). "First test of the Falcon 9-R (reusable) ignition system" (Tweet) – via Twitter.
- Belfiore, Michael (December 9, 2013). "The Rocketeer". Foreign Policy. Archived from the original on December 10, 2013. Retrieved December 11, 2013.
- Belfiore, Michael (September 30, 2013). "Musk: SpaceX Now Has "All the Pieces" For Truly Reusable Rockets". Popular Mechanics. Archived from the original on October 12, 2013. Retrieved October 17, 2013.
- Amos, Jonathan (September 30, 2013). "Recycled rockets: SpaceX calls time on expendable launch vehicles". BBC News. Archived from the original on October 3, 2013. Retrieved October 2, 2013.
- Messier, Doug (September 29, 2013). "Falcon 9 Launches Payloads into Orbit From Vandenberg". Parabolic Arc. Archived from the original on September 30, 2013. Retrieved September 30, 2013.
- Norris, Guy (April 28, 2014). "SpaceX Plans For Multiple Reusable Booster Tests". Aviation Week. Archived from the original on April 26, 2014. Retrieved May 17, 2014.
The April 17 F9R Dev 1 flight, which lasted under 1 min., was the first vertical landing test of a production-representative recoverable Falcon 9 v1.1 first stage, while the April 18 cargo flight to the ISS was the first opportunity for SpaceX to evaluate the design of foldable landing legs and upgraded thrusters that control the stage during its initial descent.
- Kremer, Ken (April 19, 2014). "SpaceX Makes Strides Towards 1st Stage Falcon Rocket Recovery during Space Station Launch". Universe Today. Archived from the original on April 19, 2014. Retrieved April 19, 2014.
- Gannes, Liz (May 30, 2013). "36:03". Tesla CEO and SpaceX Founder Elon Musk: The Full D11 Interview (Video). All Things D (Video interview). Retrieved May 31, 2013.
hopeful that sometime in the next couple of years we'll be able to achieve full and rapid reusability of the first stage—which is about three-quarters of the cost of the rocket—and then with a future design architecture, achieve full reusability.
- Junod, Tom (November 15, 2012). "Triumph of His Will". Esquire. Archived from the original on February 7, 2015. Retrieved April 5, 2014.
- Boyle, Alan (May 21, 2014). "Elon Musk's SpaceX Plans DragonFly Landing Tests". NBC News. Archived from the original on February 26, 2017. Retrieved May 22, 2014.
-
Shotwell, Gwynne (June 4, 2014). Discussion with Gwynne Shotwell, President and COO, SpaceX. Atlantic Council. Event occurs at 22:35–26:20. Retrieved June 9, 2014.
This technology element [reusable launch vehicle technology] all this innovation is being done by SpaceX alone, no one is paying us to do it. The government is very interested in the data we are collecting on this test series. ... This is the kind of thing that entrepreneurial investment and new entrants/innovators can do for an industry: fund their own improvements, both in the quality of their programs and the quality of their hardware, and the speed and cadence of their operations.
- Clark, Stephen (June 6, 2014). "SpaceX to balance business realities, rocket innovation". Spaceflight Now. Archived from the original on September 15, 2014. Retrieved September 5, 2014.
SpaceX is using private capital to develop and demonstrate the Falcon 9 rocket's reusability. SpaceX has not disclosed how much the reusable rocket program will cost
- Clark, Stephen (March 31, 2017). "SpaceX flies rocket for second time in historic test of cost-cutting technology". Spaceflight Now. Archived from the original on May 16, 2020. Retrieved April 22, 2017.
Musk said SpaceX made the Falcon 9 rocket’s first stage reusable with entirely private funding, investing at least $1 billion in the effort [...]
- Berger, Brian (July 21, 2014). "SpaceX Releases Footage of Falcon 9 First-stage Splashdown". SpaceNews. Archived from the original on July 26, 2014. Retrieved July 23, 2014.
- Elon Musk interview at MIT, October 2014. October 24, 2014 – via YouTube.
- Jessica Orwig (December 25, 2015). "Elon Musk's SpaceX already knows what it's going to do with the history-making rocket — but it's not what you think". Business Insider. Archived from the original on September 6, 2021. Retrieved December 25, 2015.
- Heath, Chris (December 12, 2015). "How Elon Musk Plans on Reinventing the World (and Mars)". GQ. Archived from the original on December 12, 2015. Retrieved December 12, 2015.
SpaceX exists to further [the vision of humans becoming multi-planetary] on several fronts: to develop the reusable rocket technology that would be needed to ferry large numbers of people, and large amounts of cargo, to Mars; ...
-
Elon Musk (September 27, 2016). Making Humans a Multiplanetary Species (video). IAC67, Guadalajara, Mexico: SpaceX. Event occurs at 9:20–10:10. Retrieved October 10, 2016.
So it is a bit tricky. Because we have to figure out how to improve the cost of the trips to Mars by five million percent ... translates to an improvement of approximately 4 1/2 orders of magnitude. These are the key elements that are needed in order to achieve a 4 1/2 order of magnitude improvement. Most of the improvement would come from full reusability—somewhere between 2 and 2 1/2 orders of magnitude—and then the other 2 orders of magnitude would come from refilling in orbit, propellant production on Mars, and choosing the right propellant.
{{cite AV media}}
: CS1 maint: location (link) - "Making Humans a Multiplanetary Species" (PDF). SpaceX. September 27, 2016. Archived from the original (PDF) on September 28, 2016. Retrieved October 16, 2016.
- Lopatto, Elizabeth (March 30, 2017). "SpaceX even landed the nose cone from its historic used Falcon 9 rocket launch". The Verge. Archived from the original on June 4, 2019. Retrieved March 31, 2017.
-
Elon Musk (July 19, 2017). Elon Musk, ISS R&D Conference (video). ISS R&D Conference, Washington DC, USA. Event occurs at 14:15–15:55. Retrieved September 13, 2017.
I think we are quite close to being able to recover the fairing. ... about a 5 or 6 million dollar piece of equipment. We've got a decent shot of recovering a fairing by the end of the year, and reflight by late this year or early next. ... Upper stage is about 20 percent of the cost of the mission. So if you get boost stage and fairing we're around 80 percent reusable. ... Think for a lot of missions, we could even bring the second stage back. So were going to try to do that, but our primary focus [for the next couple of years will be crew Dragon].
- "SpaceX successfully launches twice-flown Falcon 9, catches fairing at sea". Archived from the original on December 9, 2020. Retrieved August 23, 2019.
- Lopatto, Elizabeth (March 30, 2017). "SpaceX even landed the nose cone from its historic used Falcon 9 rocket launch". The Verge. Archived from the original on June 4, 2019. Retrieved March 31, 2017.
- Gwynne Shotwell (June 17, 2013). Singapore Satellite Industry Forum 2013 - Opening Keynote. Event occurs at 16:15–17:05. Retrieved April 9, 2016.
The Dragon capsule has a shape that is stable on reentry from orbit, whereas rocket states traditionally are not stable on reentry, so there is a lot of software involved, a lot of guidance navigation and control involved, and a lot of thermal protection required; so we have to make advances in all those areas. We also have to restart the engines supersonically.
- Gwynne Shotwell (June 17, 2013). Singapore Satellite Industry Forum 2013 - Opening Keynote. Retrieved April 9, 2016.
- Gwynne Shotwell (March 21, 2014). Broadcast 2212: Special Edition, interview with Gwynne Shotwell (audio file). The Space Show. Event occurs at 51;50–52;55. 2212. Archived from the original (mp3) on March 22, 2014. Retrieved March 22, 2014.
- "X MARKS THE SPOT: FALCON 9 ATTEMPTS OCEAN PLATFORM LANDING". SpaceX. December 16, 2014. Archived from the original on December 17, 2014. Retrieved December 17, 2014.
A key upgrade to enable precision targeting of the Falcon 9 all the way to touchdown is the addition of four hypersonic grid fins placed in an X-wing configuration around the vehicle, stowed on ascent and deployed on reentry to control the stage’s lift vector. Each fin moves independently for roll, pitch and yaw, and combined with the engine gimbaling, will allow for precision landing – first on the autonomous spaceport drone ship, and eventually on land.
- Blackmore, Lars (Winter 2016). "Autonomous Precision Landing of Space Rockets" (PDF). The Bridge, National Academy of Engineering. 46 (4): 15–20. ISSN 0737-6278. Archived (PDF) from the original on January 10, 2017. Retrieved January 15, 2017.
- "SpaceX Doubleheader Part 2 – Falcon 9 conducts Iridium NEXT-2 launch – NASASpaceFlight.com". www.nasaspaceflight.com. June 25, 2017. Archived from the original on November 11, 2020. Retrieved July 4, 2017.
- Rosenberg, Zach (March 21, 2013). "SpaceX Merlin 1D qualified for flight". Flightglobal. Archived from the original on October 30, 2013. Retrieved March 18, 2014.
- "SpaceX Falcon 9 v1.1 Data Sheet". Space Launch Report. March 12, 2014. Archived from the original on November 11, 2020. Retrieved March 18, 2014.
- Boyle, Alan (May 2, 2013). "SpaceX's Elon Musk shows off Grasshopper test rocket's latest hop". NBC News. Archived from the original on March 11, 2013. Retrieved March 9, 2013.
- "Woo-hoo! Awesome SpaceX Grasshopper "Hover-Slam" Rocket Launch Doubles Previous Height". Daily Kos. March 9, 2013. Archived from the original on May 23, 2013. Retrieved May 2, 2013.
- Grasshopper 325m Test | Single Camera (Hexacopter). YouTube. SpaceX. June 14, 2013. Retrieved July 6, 2013.
- "SpaceX debuts new model of the Falcon 9 rocket designed for astronauts". May 11, 2018. Archived from the original on April 1, 2021. Retrieved August 23, 2019.
- "Landing Legs". SpaceX.com. July 29, 2013. Archived from the original on May 20, 2015. Retrieved December 4, 2013.
The Falcon 9 first stage carries landing legs which will deploy after stage separation and allow for the rocket’s soft return to Earth. The four legs are made of state-of-the-art carbon fiber with aluminum honeycomb. Placed symmetrically around the base of the rocket, they stow along the side of the vehicle during liftoff and later extend outward and down for landing.
- "Falcon Heavy Landing Legs". SpaceX.com. April 12, 2013. Archived from the original on June 11, 2015. Retrieved December 4, 2013.
The Falcon Heavy first stage center core and boosters each carry landing legs, which will land each core safely on Earth after takeoff. After the side boosters separate, the center engine in each will burn to control the booster’s trajectory safely away from the rocket. The legs will then deploy as the boosters turn back to Earth, landing each softly on the ground. The center core will continue to fire until stage separation, after which its legs will deploy and land it back on Earth as well. The landing legs are made of state-of-the-art carbon fiber with aluminum honeycomb. The four legs stow along the sides of each core during liftoff and later extend outward and down for landing.
- Lindsey, Clark (May 2, 2013). "SpaceX shows a leg for the "F-niner"". NewSpace Watch. Archived from the original on June 30, 2013. Retrieved May 2, 2013.
F9R (pronounced F-niner) shows a little leg. Design is a nested, telescoping piston w A frame... High pressure helium. Needs to be ultra light.
- Bergin, Chris (February 28, 2014). "SpaceX outlines CRS-3 landing legs plan toward first stage recovery ambitions". NASAspaceflight.com. Archived from the original on June 1, 2014. Retrieved May 10, 2014.
- Wall, Mike (June 7, 2016). "SpaceX's Leaning Rocket Tower Comes Ashore (Photos)". Archived from the original on June 8, 2016. Retrieved June 7, 2016.
- "Elon Musk on Twitter". Twitter. Archived from the original on September 3, 2017. Retrieved June 8, 2016.
The crush core in the Falcon legs is reusable after soft landings, but needs to be replaced after hard.
- "SpaceX's new price chart illustrates performance cost of reusability". May 2, 2016. Archived from the original on September 5, 2021. Retrieved August 23, 2019.
- "Postlanding teleconference with Elon Musk". December 22, 2015. Archived from the original on January 9, 2016. Retrieved December 25, 2015.
- Bill Harwood (December 22, 2015). "Experts applaud SpaceX rocket landing, potential savings". CBS News. Archived from the original on December 24, 2015. Retrieved December 25, 2015.
- Boozer, R.D. (March 10, 2014). "Rocket reusability: a driver of economic growth". The Space Review. Archived from the original on April 6, 2015. Retrieved March 25, 2014.
- Belfiore, Michael (April 22, 2014). "SpaceX Brings a Booster Safely Back to Earth". MIT Technology Review. Retrieved April 25, 2014.
- Orwig, Jessica (November 25, 2014). "Elon Musk Just Unveiled A Game-Changing Ocean Landing Pad For His Reusable Rockets". Business Insider. Archived from the original on October 26, 2017. Retrieved December 11, 2014.
The first successful "soft landing" of a Falcon 9 rocket happened in April of this year
- Kothari, Ajay P. (April 14, 2014). "Robust and reusable?". The Space Review. Archived from the original on April 15, 2014. Retrieved April 14, 2014.
- Messier, Doug (January 14, 2014). "Shotwell: Reusable Falcon 9 Would Cost $5 to $7 Million Per Launch". Parabolic Arc. Archived from the original on February 16, 2017. Retrieved January 15, 2014.
- Foust, Jeff (March 24, 2014). "Reusability and other issues facing the launch industry". The Space Review. Archived from the original on March 28, 2014. Retrieved April 1, 2014.
- Gwynne Shotwell (March 21, 2014). Broadcast 2212: Special Edition, interview with Gwynne Shotwell (audio file). The Space Show. Event occurs at 08:15–11:20. 2212. Archived from the original (mp3) on March 22, 2014. Retrieved March 22, 2014.
[Falcon 9 v1.1] vehicle has thirty percent more performance than what we put on the web and that extra performance is reserved for us to do our reusability and recoverability [tests] ... current vehicle is sized for reuse.
- Bergin, Chris (April 22, 2014). "Rockets that return home – SpaceX pushing the boundaries". NASAspaceflight.com. Archived from the original on April 25, 2014. Retrieved April 23, 2014.
- Wall, Mike (September 7, 2014). "Dazzling SpaceX Nighttime Launch Sends AsiaSat 6 Satellite Into Orbit". SPACE.com. Archived from the original on October 2, 2015. Retrieved September 7, 2014.
SpaceX's work with the F9R is part of an effort to develop fully and rapidly reusable launch systems, a key priority for the company. Such technology could slash the cost of spaceflight by a factor of 100.
- Peter B. de Selding, Space News (May 31, 2013). "SpaceX Chief Says Reusable First Stage Will Slash Launch Costs". Space.com. Archived from the original on June 25, 2015. Retrieved June 20, 2015.
- "SpaceX's Plan Shows Aggressive Investment In R&D". Aviation Week. April 28, 2014. Archived from the original on April 13, 2015. Retrieved May 17, 2014.
- "SpaceX says reusable stage could cut prices 30 percent, plans November Falcon Heavy debut". SpaceNews.com. March 10, 2016. Retrieved May 27, 2017.
- "Elon Musk on Twitter". Archived from the original on July 16, 2018. Retrieved April 30, 2016.
- Kelly, Emre (March 31, 2017). "Things we learned after SpaceX's historic Falcon 9 relaunch and landing". Florida Today. Archived from the original on March 9, 2019. Retrieved April 1, 2017.
- "SpaceX: Elon Musk breaks down the cost of reusable rockets". August 21, 2020. Archived from the original on August 23, 2020. Retrieved August 22, 2020.
- Clash, Jim (April 2014). "Elon Musk Interview". AskMen. Archived from the original on September 3, 2014. Retrieved September 27, 2014.
Expendable rockets, which many smart people have worked on in the past, get maybe 2% of liftoff mass to orbit -- really not a lot. Then, when they’ve tried reusability, it’s resulted in negative payload, a 0 to 2% minus payload [laughs]. The trick is to figure out how to create a rocket that, if it were expendable, is so efficient in all of its systems that it would put 3% to 4% of its mass into orbit. On the other side, you have to be equally clever with the reusability elements such that the reusability penalty is no more than 2%, which would leave you with a net ideally of still 2% of usable load to orbit in a reusable scenario, if that makes sense. You have to pry those two things apart: Push up payload to orbit, push down the mass penalty for reusability -- and have enough left over to still do useful work.
- "National Press Club: The Future of Human Spaceflight". YouTube. September 29, 2011. Archived from the original on May 15, 2014. Retrieved February 19, 2014.
- ORBCOMM-2 Full Launch Webcast. SpaceX. December 21, 2015. Event occurs at 25:25. Retrieved April 9, 2016.
- "SpaceX gaining substantial cost savings from reused Falcon 9". April 5, 2017.
- "SpaceX Falcon 9 booster spotted in Southern California on journey to Florida". August 22, 2019. Archived from the original on August 22, 2019. Retrieved August 23, 2019.
- Abbott, Joseph (May 8, 2013). "SpaceX's Grasshopper leaping to NM spaceport". Waco Tribune. Archived from the original on August 5, 2020. Retrieved October 25, 2013.
- Foust, Jeff (May 5, 2014). "Following up: reusability, B612, satellite servicing". The Space Review. Archived from the original on May 6, 2014. Retrieved May 6, 2014.
- Wang, Brian (March 23, 2013). "Spacex May try to "land / recover" the first stage of it next Falcon 9 v1.1 launch this summer". Next Big Future. Archived from the original on March 27, 2013. Retrieved April 6, 2013.
- Klotz, Irene (February 24, 2014). "SpaceX Falcon Rocket to Test Landing Legs". Discovery News. Archived from the original on March 2, 2014. Retrieved February 25, 2014.
- Bergin, Chris (July 28, 2014). "SpaceX Roadmap building on its rocket business revolution". NASAspaceflight. Archived from the original on July 30, 2014. Retrieved July 28, 2014.
At this point, we are highly confident of being able to land successfully on a floating launch pad or back at the launch site and refly the rocket with no required refurbishment
- Abbott, Joseph (April 17, 2014). "Grasshopper's successor flies at SpaceX's McGregor site". Waco Tribune. Archived from the original on June 10, 2020. Retrieved April 18, 2014.
- Foust, Jeff (August 23, 2014). "Falcon 9 test vehicle destroyed in accident". NewSpace Journal. Archived from the original on August 25, 2014. Retrieved August 23, 2014.
- Klotz, Irene (September 27, 2011). "A rocket that lifts off—and lands—on launch pad". NBC News. Archived from the original on December 3, 2013. Retrieved November 23, 2011.
- Lindsey, Clark (October 2, 2012). "A 2nd-gen Grasshopper + A new video of first hop". NewSpace Watch. Archived from the original on January 4, 2013. Retrieved November 4, 2012.
-
Foust, Jeff (November 7, 2018). "SpaceX to modify Falcon 9 upper stage to test BFR technologies". SpaceNews. Retrieved November 8, 2018.
Falcon 9 second stage will be upgraded to be like a mini-BFR Ship," Musk said. The BFR’s upper stage is sometimes referred to as a "spaceship
- SpaceX to build small version of BFR's spaceship for use on Falcon 9, says Elon Musk Archived November 8, 2018, at the Wayback Machine. Eric Ralph, Teslarati. 7 November 2018.
- SpaceX CEO Elon Musk kills mini BFR spaceship 12 days after announcing it. Archived December 15, 2018, at the Wayback Machine Eric Ralph, Teslarati. 20 November 2018.
- Clark, Stephen (July 9, 2012). "Reusable rocket prototype almost ready for first liftoff". Spaceflight Now. Archived from the original on May 21, 2013. Retrieved July 13, 2012.
SpaceX has constructed a half-acre concrete launch facility in McGregor, and the Grasshopper rocket is already standing on the pad, outfitted with four insect-like silver landing legs.
- "Grasshopper Completes Highest Leap to Date". SpaceX.com. March 10, 2013. Archived from the original on August 22, 2013. Retrieved April 21, 2013.
- Boyle, Alan (August 14, 2013). "SpaceX's Grasshopper test rocket flies sideways successfully". NBC News. Archived from the original on August 17, 2013. Retrieved August 15, 2013.
- Grasshopper flies to its highest height to date. SpaceX. October 12, 2013. Retrieved April 9, 2016.
- Klotz, Irene (October 17, 2013). "SpaceX Retires Grasshopper, New Test Rig To Fly in December". Space News. Archived from the original on October 21, 2013. Retrieved October 21, 2013.
- @elonmusk (August 22, 2014). "Three engine F9R Dev1 vehicle auto-terminated during test flight. No injuries or near injuries. Rockets are tricky …" (Tweet). Retrieved April 9, 2016 – via Twitter.
- James, Michael; Salton, Alexandria; Downing, Micah (November 12, 2013). "Draft Environmental Assessment for Issuing an Experimental Permit to SpaceX for Operation of the Dragon Fly Vehicle at the McGregor Test Site, Texas, May 2014 – Appendices" (PDF). Blue Ridge Research and Consulting, LCC. p. 12. Archived (PDF) from the original on September 24, 2015. Retrieved May 23, 2014.
- Abbott, Joseph (May 22, 2014). "Grasshopper to DragonFly: SpaceX seeks approval for new McGregor testing". Waco Tribune. Archived from the original on June 6, 2020. Retrieved May 23, 2014.
- Gebhardt, Chris (December 31, 2015). "Year In Review, Part 4: SpaceX and Orbital ATK recover and succeed in 2015". NASASpaceFlight.com. Archived from the original on January 2, 2016. Retrieved January 1, 2016.
- Dean, James (December 1, 2015). "SpacexSpaceX wants to land next booster at Cape Canaveral". Florida Today. Archived from the original on December 10, 2015. Retrieved December 2, 2015.
- "SpaceX aims for Sunday launch and ground landing". Orlando Sentinel. December 20, 2015. Archived from the original on December 21, 2015. Retrieved December 20, 2015.
- Grush, Loren (December 21, 2015). "SpaceX successfully landed its Falcon 9 rocket after launching it to space". The Verge. Archived from the original on June 28, 2017. Retrieved April 9, 2016.
- O'Kane, Sean (December 21, 2015). "SpaceX's 'reusable' Falcon 9 rocket won't fly again, Elon Musk says". The Verge. Archived from the original on December 23, 2015. Retrieved December 23, 2015.
- "SpaceX Test Fires Recovered Falcon 9 Booster in Major Step To Reusable Rockets - Universe Today". Universe Today. January 16, 2016. Archived from the original on December 2, 2016. Retrieved January 28, 2017.
- "Returned falcon 9 booster fires up for static fire test". Spaceflight 101. January 15, 2016. Archived from the original on April 22, 2016. Retrieved January 18, 2016.
- "SpaceX Tests Recovered Falcon 9 Stage and Prepares for Next Launch". January 15, 2016. Retrieved January 15, 2016.
- Coldewey, Devin (January 7, 2016). "SpaceX Plans Drone Ship Rocket Landing for Jan. 17 Launch". NBC News. Archived from the original on December 1, 2017. Retrieved January 8, 2016.
- Clark, Stephen (January 18, 2016). "SpaceX narrowly misses booster landing at sea". Spaceflight Now. Archived from the original on January 22, 2016. Retrieved January 18, 2016.
- Boyle, Alan (January 17, 2016). "SpaceX rocket launches satellite, but tips over during sea landing attempt". GeekWire. Archived from the original on January 30, 2016. Retrieved January 18, 2016.
- Musk, Elon (January 17, 2016). "Flight 21 landing and breaking a leg". Instagram. Archived from the original on December 11, 2017. Retrieved June 5, 2016.
- Clark, Stephen (February 24, 2016). "Falcon 9 rocket to give SES 9 telecom satellite an extra boost". Spaceflight Now. Archived from the original on March 5, 2016. Retrieved March 7, 2016.
SES’s contract with SpaceX called for the rocket to deploy SES 9 into a "sub-synchronous" transfer orbit with an apogee around 16,155 miles (26,000 kilometers) in altitude. Such an orbit would require SES 9 to consume its own fuel to reach a circular 22,300-mile-high perch, a trek that Halliwell said was supposed to last 93 days. The change [SpaceX offered] in the Falcon 9’s launch profile will put SES 9 into an initial orbit with an apogee approximately 24,419 miles (39,300 kilometers) above Earth, a low point 180 miles (290 kilometers) up, and a track tilted about 28 degrees to the equator
- "SES-9 Mission" (PDF). Press Kit. SpaceX. February 23, 2016. Archived (PDF) from the original on July 27, 2019. Retrieved February 24, 2016.
This mission is going to a Geostationary Transfer Orbit. Following stage separation, the first stage of the Falcon 9 will attempt an experimental landing on the "Of Course I Still Love You" droneship. Given this mission’s unique GTO profile, a successful landing is not expected.
- Bergin, Chris (November 24, 2014). "SpaceX's Autonomous Spaceport Drone Ship ready for action". NasaSpaceFlight.com. Archived from the original on July 26, 2019. Retrieved November 24, 2014.
- Drake, Nadia (April 8, 2016). "SpaceX Rocket Makes Spectacular Landing on Drone Ship". National Geographic. Archived from the original on April 20, 2016. Retrieved April 8, 2016.
To space and back, in less than nine minutes? Hello, future.
- SpaceX (April 8, 2016). "CRS-8 Dragon Hosted Webcast". Archived from the original on February 4, 2021. Retrieved May 14, 2016 – via YouTube.
- Elon Musk [@elonmusk] (May 6, 2016). "Yeah, this was a three engine landing burn, so triple deceleration of last flight. That's important to minimize gravity losses" (Tweet). Retrieved May 8, 2016 – via Twitter.
- "SpaceX Falcon 9 first stage booster suffered 'max' damage on landing". Archived from the original on December 16, 2017. Retrieved May 26, 2016.
- Elon Musk [@elonmusk] (January 19, 2016). "My best guess for 2016: ~70% landing success rate (so still a few more RUDs to go), then hopefully improving to ~90% in 2017" (Tweet) – via Twitter.
- Landed Falcon 9 First Stage Test Firing. SpaceX. July 28, 2016.
- "Live coverage: SpaceX aims for Thursday launch of previously-flown rocket - Spaceflight Now". Archived from the original on April 23, 2018. Retrieved March 31, 2017.
- Masunaga, Samantha (August 30, 2016). "SpaceX signs first customer for launch of a reused rocket". Los Angeles Times. Archived from the original on December 8, 2020. Retrieved August 30, 2016.
- Henry, Caleb (August 30, 2016). "SES Becomes First Reusable Rocket Customer for SpaceX". Via Satellite. Archived from the original on November 7, 2016. Retrieved November 6, 2016.
- Graham, William (June 23, 2017). "SpaceX Falcon 9 success with second flight involving BulgariaSat-1 mission". NASASpaceFlight.com. Archived from the original on April 22, 2021. Retrieved June 25, 2017.
- Clark, Stephen (March 27, 2017). "Hotfire test completed ahead of milestone Falcon 9 launch Thursday". Spaceflight Now. Archived from the original on March 30, 2017. Retrieved April 1, 2017.
- "SpaceX makes history by successfully launching first recycled rocket booster". The Daily Telegraph. Reuters. March 31, 2017. Archived from the original on February 11, 2018. Retrieved April 1, 2017.
- Berger, Eric (May 12, 2018). "After "crazy hard" development, SpaceX's Block 5 rocket has taken flight". Ars Technica. Retrieved June 5, 2018.
- "SpaceX Booster Flight History - RocketLaunch.Live". www.rocketlaunch.live. Retrieved June 27, 2022.
- Henry, Caleb (June 28, 2019). "SpaceX targets 2021 commercial Starship launch". SpaceNews. Archived from the original on August 28, 2019. Retrieved June 29, 2019.
- March 2020, Amy Thompson 18 (March 18, 2020). "SpaceX launches 60 Starlink satellites into orbit, misses rocket landing". Space.com. Archived from the original on March 30, 2021. Retrieved March 19, 2020.
- "SpaceX loses Falcon Heavy's center core in an otherwise successful launch". June 25, 2019. Archived from the original on February 8, 2021. Retrieved May 29, 2021.
- SpaceX Test-Fires New Falcon 9 Block 5 Rocket Ahead of Maiden Flight (Updated) Archived April 7, 2019, at the Wayback Machine. Robin Seemangal, Popular Mechanics. 4 May 2018.
- "SpaceX expends "old-gen" Falcon 9 to ready for upcoming rapid reuse rocket". www.teslarati.com. April 3, 2018. Archived from the original on April 7, 2018. Retrieved April 6, 2018.
- "SpaceX flies historic 10th mission of a Falcon 9 as Starlink constellation expands". NASASpaceFlight. May 9, 2021. Archived from the original on May 16, 2021. Retrieved May 9, 2021.
- Leone, Dan (June 1, 2015). "Beachcomber Finds SpaceX Rocket Wreckage in Bahamas". SpaceNews. Retrieved March 8, 2018.
- Clark, Stephen (June 1, 2018). "New photos illustrate progress in SpaceX's fairing recovery attempts – Spaceflight Now". spaceflightnow.com. Pole Star Publications Ltd. Archived from the original on June 16, 2018. Retrieved August 7, 2018.
- Foust, Jeff (May 26, 2021). "SpaceX sets Falcon 9 fairing reuse mark with Starlink launch". SpaceNews. Retrieved May 28, 2021.
- Etherington, Darrell (February 20, 2018). "SpaceX to use a net boat called 'Mr. Steven' to recover next rocket fairing". TechCrunch. Archived from the original on February 20, 2018. Retrieved February 20, 2018.
- Baylor, Michael (February 25, 2018). "SpaceX's Mr. Steven, the FSV fairing catcher – NASASpaceFlight.com". NASASpaceFlight.com. Archived from the original on February 25, 2018. Retrieved February 26, 2018.
- Graham, William (February 20, 2018). "SpaceX Falcon 9 set for PAZ launch with Starlink demo and new fairing – NASASpaceFlight.com". NASASpaceFlight.com. Archived from the original on March 9, 2021. Retrieved February 21, 2018.
- Elon Musk [@elonmusk] (February 22, 2018). "Missed by a few hundred meters, but fairing landed intact in water. Should be able catch it with slightly bigger chutes to slow down descent" (Tweet) – via Twitter.
- Bartels, Meghan (July 25, 2018). "SpaceX Lands Rocket in Harshest Conditions to Date and Attempts to Catch Fairing". Space.com. Purch. Archived from the original on January 26, 2021. Retrieved August 7, 2018.
- Wall, Mike (July 13, 2018). "SpaceX Gives Nose-Cone-Catching Boat 'Mr. Steven' a Bigger Net". Space.com. Purch. Archived from the original on August 8, 2018. Retrieved August 7, 2018.
- Ralph, Eric (October 19, 2018). "SpaceX's Mr. Steven highlights ambiguity of Falcon fairing catches with port return". Teslarati.com. Archived from the original on October 30, 2018. Retrieved October 30, 2018.
- Wall, Mike (April 15, 2019). "SpaceX Recovered Falcon Heavy Nose Cone, Plans to Re-fly it This Year (Photos)". Space.com. Purch. Archived from the original on February 9, 2021. Retrieved April 16, 2019.
- "Successful launch continues deployment of SpaceX's Starlink network". November 11, 2019. Archived from the original on November 17, 2020. Retrieved November 11, 2019.
- Ralph, Eric (June 25, 2019). "SpaceX successfully catches first Falcon Heavy fairing in Mr. Steven's/Ms. Tree's net". Teslarati.com. Archived from the original on June 26, 2019. Retrieved June 25, 2019.
- berger, Eric (April 9, 2021). "Rocket Report: SpaceX abandons catching fairings". Ars Technica. Archived from the original on April 20, 2021. Retrieved April 28, 2021.
- "DOUG (Offshore Supply Ship) Registered in USA - Vessel details, Current position and Voyage information - IMO 9529889, MMSI 368485000, Call Sign WDF2598". www.marinetraffic.com. Retrieved August 25, 2021.
- Ananian, C. Scott (October 24, 2014). Elon Musk MIT Interview. Event occurs at 14:20. Retrieved July 16, 2017 – via YouTube.
- Russell Borogove (July 31, 2015). "reuse – How does SpaceX plan to achieve reusability of the Falcon 9 *second* stage?". StackExchange. Archived from the original on December 22, 2015. Retrieved January 5, 2016.
-
Hanry, Caleb (November 21, 2017). "SpaceX aims to follow a banner year with an even faster 2018 launch cadence". SpaceNews. Retrieved January 15, 2018.
Shotwell said SpaceX plans to attempt second stage recoveries from the existing Falcon family is less to reuse them, and more to learn about reusability in preparation for the BFR’s second stage
- Baylor, Michael (May 17, 2018). "With Block 5, SpaceX to increase launch cadence and lower prices". NASASpaceFlight.com. Archived from the original on May 18, 2018. Retrieved May 22, 2018.
Musk: "in the upcoming flights [SpaceX will] gather data about the reentry experience of the upper stage. Previously, we had not put a lot of effort into gathering data from the upper stage after it does its disposal burn. We will monitoring at what altitude and speed the stage breaks up…" Collecting this data is not easy. Musk explained that "it’s tricky because it comes in like a meteor. It’s sort of like a ball of plasma. You can only broadcast diagonally backwards, so we will be looking to communicate, probably [with] the Iridium constellation, and try to transmit basic data about temperature, basic health of the stage, velocity, and altitude."
-
Elon Musk (September 29, 2017). Becoming a Multiplanet Species (video). 68th annual meeting of the International Astronautical Congress in Adelaide, Australia: SpaceX. Retrieved March 8, 2018 – via YouTube.
{{cite AV media}}
: CS1 maint: location (link) - Gebhardt, Chris (July 26, 2017). "TDRS-M given priority over CRS-12 Dragon as launch dates realign". NASASpaceFlight. Archived from the original on August 18, 2017. Retrieved January 11, 2020.
- @SpaceX (July 19, 2019). "The Dragon spacecraft supporting this mission previously visited the @space_station in April 2015 and December 2017" (Tweet) – via Twitter.
- @SpaceX (November 27, 2019). "The Dragon spacecraft supporting this mission previously flew in support of our fourth and eleventh commercial resupply missions" (Tweet) – via Twitter.
- Graham, William (December 5, 2019). "CRS-19 Dragon completes journey to the ISS". NASASpaceFlight. Archived from the original on December 21, 2019. Retrieved January 11, 2020.
- Ralph, Eric (August 28, 2019). "SpaceX has no plans to reuse Crew Dragon spaceships on NASA astronaut launches". Teslarati. Archived from the original on January 11, 2020. Retrieved January 11, 2020.
- Ralph, Eric (June 9, 2020). "SpaceX wins NASA approval to launch astronauts on reused rockets and spacecraft". Teslarati. Retrieved June 10, 2020.
- "NASA SpaceX Agreement, change for Capsule reuse". beta.sam.gov. Retrieved August 14, 2020.
- "SpaceX to lease building at Port Canaveral, build another one". Florida Today. August 24, 2016. Archived from the original on January 7, 2019. Retrieved August 24, 2016.
- Inman, Jennifer Ann; Horvath, Thomas J.; Scott, Carey Fulton (August 24, 2021). "SCIFLI Starship Reentry Observation (SSRO) ACO (SpaceX Starship)". NASA. Archived from the original on October 11, 2021. Retrieved October 12, 2021.
- Etherington, Darrell (September 29, 2019). "Elon Musk says Starship should reach orbit within six months – and could even fly with a crew next year". TechCrunch. Archived from the original on September 24, 2021. Retrieved September 24, 2021.
- Howell, Elizabeth (August 21, 2021). "Every SpaceX Starship explosion and what Elon Musk and team learned from them (video)". Space.com. Archived from the original on September 3, 2021. Retrieved October 11, 2021.
- "STARSHIP USERS GUIDE" (PDF). March 2020. Retrieved November 22, 2021.
- Chaben, Jack B. (2020). "Extending Humanity's Reach: A Public-Private Framework for Space Exploration". Journal of Strategic Security. University of South Florida Board of Trustees. 13 (3): 90. doi:10.5038/1944-0472.13.3.1811. JSTOR 26936546.
- Berger, Eric (June 8, 2021). "Relativity has a bold plan to take on SpaceX, and investors are buying it". Ars Technica. Archived from the original on June 8, 2021. Retrieved October 14, 2021.
- Foust, Jeff (November 14, 2005). "Big plans for SpaceX". The Space Review. Archived from the original on November 24, 2005. Retrieved September 16, 2018.
- Markusic, Tom (July 28, 2010). "Series of presentation of SpaceX in July 2010" (pdf). SpaceX. p. 4. Archived from the original on October 30, 2013. Retrieved October 9, 2021.
- Coppinger, Rob (November 23, 2012). "Huge Mars Colony Eyed by SpaceX Founder Elon Musk". Space.com. Archived from the original on February 27, 2021. Retrieved September 23, 2021.
- Bergin, Chris (September 27, 2016). "SpaceX reveals ITS Mars game changer via colonization plan". NASASpaceFlight.com. Archived from the original on September 28, 2016. Retrieved September 27, 2016.
- Belluscio, Alejandro G. (October 3, 2016). "ITS Propulsion – The evolution of the SpaceX Raptor engine". NASASpaceFlight.com. Archived from the original on November 22, 2018. Retrieved October 3, 2016.
- Richardson, Derek (September 27, 2016). "Elon Musk Shows Off Interplanetary Transport System". Spaceflight Insider. Archived from the original on October 1, 2016. Retrieved October 3, 2016.
- Mosher, Dave (February 16, 2019). "Elon Musk says SpaceX is developing a 'bleeding' heavy-metal rocket ship. Making it work may be 100 times as hard as NASA's most difficult Mars mission, one expert says". Business Insider. Archived from the original on July 12, 2021. Retrieved September 24, 2021.
- Malik, Tariq (September 14, 2018). "SpaceX Has Apparently Tweaked Its Giant BFR Rocket Design. And It Looks Awesome!". Space.com. Archived from the original on August 25, 2021. Retrieved September 24, 2021.
- Burghardt, Thomas (January 19, 2021). "SpaceX acquires former oil rigs to serve as floating Starship spaceports". NASASpaceFlight.com. Archived from the original on January 20, 2021. Retrieved January 20, 2021.
- "SpaceX's Elon Musk renames his big rocket 'Starship'". phys.org. November 20, 2018. Archived from the original on June 18, 2021. Retrieved September 17, 2021.
- Grush, Loren (September 17, 2018). "Elon Musk reveals updated design for future SpaceX Mars rocket". The Verge. Archived from the original on April 12, 2021. Retrieved September 24, 2021.
- Berger, Eric (January 8, 2019). "Here's why Elon Musk is tweeting constantly about a stainless-steel starship". Ars Technica. Archived from the original on December 9, 2019. Retrieved September 24, 2021.
- Malik, Tariq (March 22, 2019). "SpaceX's Hexagon Tiles for Starship Heat Shield Pass Fiery Test". Space.com. Archived from the original on March 6, 2021. Retrieved September 24, 2021.
- Wall, Mike (October 20, 2020). "SpaceX fires up 3-engine Starship SN8 prototype ahead of epic test flight". Space.com. Archived from the original on February 27, 2021. Retrieved September 24, 2021.
- Etherington, Darrell (September 30, 2019). "SpaceX details Starship and Super Heavy in new website". TechCrunch. Archived from the original on September 11, 2021. Retrieved September 11, 2021.
- Foust, Jeff (August 27, 2019). "SpaceX's Starhopper completes test flight". SpaceNews. Retrieved August 28, 2019.
- "SpaceX's Starship is a new kind of rocket, in every sense". The Economist. October 5, 2019. Archived from the original on November 11, 2019. Retrieved November 23, 2019.
- Marley, Ronnie (November 20, 2019). "SpaceX moving to MK3 vehicle following incident at Boca Chica Facility". CBS News. Archived from the original on December 17, 2019. Retrieved March 10, 2020.
- Torbet, Georgina (April 27, 2020). "SpaceX Starship Successfully Passes Pressure Testing". Digital Trends. Archived from the original on March 1, 2021. Retrieved September 23, 2021.
- Wall, Mike (March 10, 2020). "SpaceX's latest Starship prototype passes big tank pressure test". Space.com. Archived from the original on March 11, 2020. Retrieved March 10, 2020.
- Bartels, Meghan (April 3, 2020). "SpaceX's Starship SN3 prototype collapses in pressure tank test". Space.com. Archived from the original on September 18, 2021. Retrieved September 28, 2021.
- Foust, Jeff (May 29, 2020). "SpaceX Starship prototype destroyed after static-fire test". SpaceNews. Retrieved May 30, 2020.
- Etherington, Darrell (August 5, 2020). "SpaceX Successfully Flies its Starship Prototype to a Height of Around 500 Feet". TechCrunch. Archived from the original on May 19, 2021. Retrieved September 18, 2021.
- Wall, Mike (September 9, 2020). "Watch SpaceX's SN6 Starship prototype soar on test flight (video)". Space.com. Archived from the original on August 29, 2021. Retrieved September 18, 2021.
- Malik, Tariq (June 23, 2020). "Boom! SpaceX pops huge Starship SN7 test tank on purpose in pressure test (videos)". Space.com. Archived from the original on July 19, 2020. Retrieved September 21, 2021.
- Wattles, Jackie (December 10, 2020). "Space X's Mars prototype rocket exploded yesterday. Here's what happened on the flight". CNN. Archived from the original on December 10, 2020. Retrieved December 10, 2020.
- Wall, Mike (November 24, 2020). "SpaceX's Starship SN8 prototype fires engines ahead of major test flight". Space.com. Archived from the original on January 23, 2021. Retrieved October 5, 2021.
- Wall, Mike (December 10, 2020). "SpaceX's Starship SN8 Prototype Soars on Epic Test Launch, with Explosive Landing". Scientific American. Archived from the original on January 23, 2021. Retrieved March 3, 2021.
- Mack, Eric (January 7, 2021). "SpaceX Starship SN9 flies high, explodes on landing just like SN8". CNET. Archived from the original on September 18, 2021. Retrieved September 20, 2021.
- Sheetz, Michael (February 2, 2021). "SpaceX's Starship prototype again explodes on landing attempt after successful launch". CNBC. Archived from the original on February 2, 2021. Retrieved September 20, 2021.
- Chang, Kenneth (March 3, 2021). "SpaceX Mars Rocket Prototype Explodes, but This Time It Lands First". The New York Times. ISSN 0362-4331. Archived from the original on June 5, 2021. Retrieved September 18, 2021.
- Bergin, Chris (March 29, 2021). "Starship SN11 lands in bits as SpaceX refine forward plan". NASASpaceFlight.com. Archived from the original on August 14, 2021. Retrieved September 18, 2021.
- Griffin, Andrew (April 1, 2021). "Elon Musk confirms SpaceX Starship exploded in 'crater'". The Independent. Archived from the original on April 1, 2021. Retrieved September 18, 2021.
- Wall, Mike (April 5, 2021). "SpaceX identifies cause of Starship SN11 prototype's crash". Space.com. Archived from the original on May 7, 2021. Retrieved September 18, 2021.
- Wall, Mike (April 13, 2021). "SpaceX's SN15 Starship prototype rolls out to launch pad". Space.com. Archived from the original on April 24, 2021. Retrieved September 18, 2021.
- Amos, Jonathan (May 5, 2021). "SpaceX Starship prototype makes clean landing". BBC News. Archived from the original on May 6, 2021. Retrieved September 18, 2021.
- Gorman, Steve (May 6, 2021). "Elon Musk's SpaceX Starship completes successful launch and landing after several fiery failures". Reuters. Archived from the original on May 6, 2021. Retrieved September 29, 2021.
- Tariq, Malik (July 20, 2021). "SpaceX test fires massive Super Heavy booster for Starship for 1st time (video)". Space.com. Archived from the original on August 3, 2021. Retrieved September 11, 2021.
- Bergin, Chris (July 3, 2021). "Booster 3 opens Super Heavy test campaign as orbital vehicles prepare to stack". NASASpaceFlight.com. Archived from the original on July 11, 2021. Retrieved September 18, 2021.
- Sheetz, Michael (August 6, 2021). "Musk: 'Dream come true' to see fully stacked SpaceX Starship rocket during prep for orbital launch". CNBC. Archived from the original on August 19, 2021. Retrieved September 24, 2021.
- Berger, Eric (September 17, 2021). "The FAA releases initial report on Boca Chica launches, and it's not terrible". Ars Technica. Archived from the original on September 20, 2021. Retrieved September 21, 2021.
- "Draft Programmatic Environmental Assessment for the SpaceX Starship/Super Heavy Launch Vehicle Program at the SpaceX Boca Chica Launch Site in Cameron County, Texas" (PDF). Federal Aviation Administration. September 17, 2021. Archived (PDF) from the original on September 17, 2021. Retrieved September 24, 2021.
This article incorporates text from this source, which is in the public domain.
- Gohd, Chelsea (October 22, 2021). "Elon Musk says SpaceX could launch Starship orbital flight test next month". Space. Space. Archived from the original on November 11, 2021. Retrieved November 11, 2021.
- "Starship Orbital – First Flight FCC Exhibit". Archived from the original on May 13, 2021. Retrieved September 10, 2021.
External links
- Video of 8th and final low-altitude Grasshopper v1.0 test flight, to 744 meters (0.462 miles), October 7, 2013.
- Low-resolution photograph of the Falcon 9 booster controlled-descent test on September 29, 2013, just moments before impacting the Atlantic ocean.
- Video of Falcon 9 Reusable Development vehicle no. 1 (F9R Dev1) 1st test flight, to 250 meters (0.16 miles), hovering and then landing just next to the launch stand, April 17, 2014.
- Video of CRS-3 booster stage landing test, April 2014: low quality, corrupted data and higher quality, after video frames recovered by open-source recovery effort by NSF team.
- On-board camera video of ORBCOMM Mission-1 booster stage landing test: Falcon 9 First Stage Return : ORBCOMM Mission, SpaceX-released video of the controlled descent test, July 2014.
- Chase-plane camera video of ORBCOMM Mission-1 booster stage landing test: Falcon 9 First Stage Reentry Footage from Plane , SpaceX-released video of the controlled descent test, released August 14, 2014.
- SpaceX rocket nails launch but narrowly misses landing test, Reuters, Irene Klotz, January 10, 2015.