21 cm RK L/22

The 21 cm RK L/22 was a 21 cm caliber Krupp gun that was purposefully designed to use a combination of prismatic gunpowder, a built-up gun barrel, and the Krupp cylindroprismatic sliding breech with broadwell ring.

21 cm RK L/22
stereogram of Krupp guns displayed at the Vienna exhibition in 1873. The 21 cm RK L/22 is third from the right
Type
Place of originKingdom of Prussia
Service history
In service1870[1]
Used by
Production history
DesignerKrupp
ManufacturerKrupp
Specifications
Mass10,327 kg (22,767 lb)[2]
Length4.708 m (15 ft 5.4 in)[3] L/22
Caliber209.2 mm (8.24 in)[3]
Breechhorizontal sliding wedge
Muzzle velocity446 m/s.[4]
Effective firing range6,000 m (20,000 ft) at 14.10° elevation[5]

Background
Main article: 21 cm RK L/19

After it had become clear that rifled cannon were required to penetrate armored ships, Prussia had set on a system of rifled breechloaders. When 15 cm (5.9 in) and 19.3 cm (7.6 in) caliber designs proved insufficient to penetrate standard 114 mm (4.5 in) armor plating, Prussia began to look at the 21 cm caliber.

In Fall 1864, the Prussian department of the navy ordered a 21 cm rifled breechloader, which it also designed. The barrel would be made of steel instead of iron, and would be massive (i.e. cast in one piece).[6] It was followed by a similar 24 cm gun and a heavier 9,000 kg version of the 21 cm gun.

Meanwhile, Prussia had bought a RML 9-inch Armstrong Gun. This was a so called Woolwich gun, which were muzzle loading British rifled guns. Prussia then held trials of this gun against the massive 21 cm gun and a 24 cm built-up gun it had acquired. In early and mid 1868, these trials showed that the Krupp 21 cm gun fired projectiles at a much slower speed than the British 9-inch gun, i.e. 320 m/s vs 404 m/s. The 24 cm built-up gun called Ring Kanone was much better, but still way too slow.[7]

Krupp understood that a built-up gun barrel was necessary to withstand the increased gunpowder load required to match the power of the Woolwich guns. It made a prototype version of the massive 21 cm gun, with a barrel of the same length, but of a built-up construction. The powder chamber was bored out to accommodate a higher charge of (prismatic gunpowder), and it had a cylindroprismatic breech and a Broadwell ring. The new cylindroprismatic breechblock or Rundkeil (the German word 'Keil' means wedge), was as its name implies almost round. It was essential to withstand the higher explosive forces found in the built-up guns.[8]

Already in late September 1868, it became known that this new 21 cm gun with simple breech was very powerful and much better than the previous 21 cm guns and the British rifled muzzle loaders. It only required some work on its accuracy. The war office then determined in late 1868 that all new guns of 21 and 24 cm would be built-up guns with Krupp's simple breech. It also decided to use ignition through the breech block.[9]

In January 1869, the Prussian War Office decided to cease all experiments with muzzle loading guns. This decision finalized the choice between Armstrong's system of Woolwich guns and Krupp's breech loading system.[10] Many of the existing Krupp 21 cm massive breechloaders were then converted to Ring Kanone. In August 1871, the German guns got new names based on the Metric system.[11] The converted guns then got the name "kurze 21 cm Marine Ring Kanone".[12] Later this name was changed to 21 cm RK L/19.

Design and development

Now that Prussia had decided to use the Krupp system, it was time to make final designs that incorporated the knowledge that had been gained from the trials. In 1869 Krupp got the order to design longer versions of the 24 and 21 cm guns, but of the same weight. Gruson got orders to improve the shot.[10] Meanwhile they worked on designing an efficient gun carriage.[13] Though the decision about whether the breechloaders would be made of cast steel or bronze was still open and would only be decided at a later date.[14]

With a new design, Krupp succeeded in increasing the rifled length of the 21 cm Ring Kanone by 3.3 calibers to 4.71 m (15 ft 5 in). The weight of the gun was 9,950 kg (9.79 long tons). The breech block weighed another 377 kg.[3]

The gun could fire an explosive Langgranate c\69 of 79.75 kg (175 lb 13 oz) and 2.5 caliber length. This had a velocity of 425 m/s (1,390 ft/s) at the mouth of the barrel. Maxium range with this shot was 6,000 m (20,000 ft).[15] The hardened (Hartguss) shot c\69 weighed 98.25 kg (216 lb 10 oz).[16] It had a velocity of 446 m/s (1,460 ft/s) at the mouth. Maxium range with this shot was 6,000 m.[5]

The barrel got the name "lange 21 cm Ringrohre", the complete gun became the "lange 21 cm Ring Kanone".[17] In 1885, the lange 21 cm Ring Kanone was renamed to 21 cm Ring Kanone L/22, abbreviated 21 cm RK L/22.[18]

Meanwhile, the Woolwich guns started to use "Pebble gunpowder". This increased the velocity of the Woolwich guns and relative to gun weight, they were again more powerful, even though this did not apply to the 21 cm RK L/22.[19] Krupp and the Germans responded by using a new prismatic powder, which allowed the use of a charge of 19 kg (41 lb 14 oz) for the 21 cm RK L/22.[20] This increased velocity to 446 m/s.[4]

Carriage

For use in armored gun turrets, Gruson built the 21 cm Minimalscharten Lafette c/72. This served to bring the horizontal and vertical turning point of the gun to the gun port, instead of it being near the trunnions.[21] There were numerous other carriages for ships and coastal use.

Obsolete

The development of the 21 cm RK L/22 kind of ended when Krupp started to develop the Mantel Ringrohr gun barrel. This consisted of a strong core in a weaker core and mantle, which were in turn surrounded by rings. This made a stronger gun barrel. In 1875/76 Krupp was testing a Mantel Ring Kanone of 21 cm with use of a 26 kg charge for a speed of 470 m/s.[22]

Use

As coastal artillery

The first use of the 21 cm RK L/22 was during the 1870 Franco-Prussian War. About a dozen where hastily sent from the factory to defend the North Sea coast.[1]

In Swinemünde / Świnoujście the 21 cm Ring Kanone was used in the Westbatterie, now the museum Zachodni Fort Artyleryjski.[23]

Near Danzig, from 1896, the battery known in Polish as Bateria nr 11, W Lasku Brzeznienskim, was armed with 6 21 cm Ring Kanone on Coastal carriages.

Ships

Notes
  1. Von Müller 1879, p. 129.
  2. Von Müller 1879, p. 289.
  3. Von Müller 1879, p. 288.
  4. Von Müller 1879, p. 155.
  5. Von Müller 1879, p. 296.
  6. Von Müller 1879, p. 43.
  7. Von Müller 1879, p. 52.
  8. Von Doppelmair 1870, p. 41.
  9. Von Müller 1879, p. 63.
  10. Von Müller 1879, p. 86.
  11. Armee Verordnungsblatt 1871, p. 194.
  12. Armee Verordnungsblatt 1871, p. 196.
  13. Von Müller 1879, p. 121.
  14. Von Müller 1879, p. 100-110.
  15. Von Müller 1879, p. 297.
  16. Von Müller 1879, p. 290.
  17. Von Müller 1879, p. 93.
  18. Marineverordnungsblatt 1885, p. 2.
  19. Von Müller 1879, p. 135.
  20. Von Müller 1879, p. 152.
  21. Von Müller 1879, p. 197.
  22. Von Müller 1879, p. 259.
  23. Fort Zachodny Historia 2023.

References
This article is issued from Wikipedia. The text is licensed under Creative Commons - Attribution - Sharealike. Additional terms may apply for the media files.