Knox-class frigate

Designated SCB No. 199C, the Knox was planned as the follow-on to the twin 5" gun-armed Garcia class frigates and the Tartar missile-equipped Brooke-class frigates. Their initial design incorporated the prior classes' pressure-fired boilers in a similar-sized hull designed around the massive bow-mounted AN/SQS-26 sonar, with increased endurance and reduced crew size. Anti-submarine armament was to consist of RUR-5 ASROC anti submarine missiles together with the QH-50 DASH drone helicopter, while defensive armament was to be the RIM-46 Sea Mauler short range anti-aircraft missile backed up by a single 5-inch/54 caliber Mark 42 gun.[3]

Drawing of a Knox-class frigate as built.

The design soon ran into problems however, with the US Navy deciding to switch to conventional 1,200 psi (8,300 kPa) boilers, requiring a redesign, and the ships became longer and heavier in order to accommodate the less compact power plants. Furthermore, Sea Mauler was cancelled in 1965, leaving the ships to complete without any anti-aircraft system except the 5" gun.[4][5]

Overhead view of Knox-class frigate USS Fanning (FF-1076)

The steam plant for these ships consists of two Combustion Engineering or Babcock & Wilcox "D" type boilers, each equipped with a high-pressure (supercharger) forced draught air supply system, with a plant working pressure of 1,200 psi (8,300 kPa) and 1,000 °F (538 °C) superheat and rated at 35,000 shp (26,000 kW) driving a single screw. This gives them a speed of 27 kn (50 km/h; 31 mph).[6][7]

The ships were designed primarily as anti-submarine warfare (ASW) platforms.[5] Their main anti-submarine sensor was the large bow-mounted AN/SQS-26CX low-frequency scanning sonar, operating as an active sonar at a frequency of about 3.5 kHz and passively at 1.5–4 kHz. The active modes of operation included direct path, to a range of about 20,000 yd (18,000 m), bottom bounce, and convergence zone, which could give ranges of up to about 70,000 yd (64,000 m), well outside the capability of ASROC, and requiring the use of a helicopter to exploit.[5][8][9] An eight-round ASROC launcher (with 16 missiles carried) was fitted between the gun turret and the bridge, backed up by four fixed 12.75 in (324 mm) Mark 32 anti-submarine torpedo tubes. A flight deck and hangar for operating the DASH drone helicopter was fitted aft.[10][5]

Ten ships were authorized in Fiscal Year 1964, sixteen in 1965, and ten each for FYs 1966, 67 and 68; six were canceled in 1968, and four more in 1969. While the FY64 and FY65 ships were ordered from four different shipyards, later ships (DE-1078 onwards) were all ordered from Avondale Shipyards in order to cut costs.[4] These ships were built on a production line, with prefabricated modules being assembled upside down, welded together and then rotated into an upright position.[10] They were originally commissioned as destroyer escorts (DEs) 1052–1097 in 1969–1974,[5] but were redesignated as frigates (FF) on 30 June 1975.[11]

The lead ship of the class, Knox (FF-1052), was laid down 5 October 1965, and commissioned 12 April 1969, at the Todd Shipyards in Seattle, Washington.[5]

The USS Joseph Hewes (FF-1078) and subsequent ships of the class were modified to enable them to serve as flagships. The primary change was a slightly different arrangement of the "Officer's Country" staterooms with additional staterooms in a new 01 level structure which replaced the open deck between the boats. The stateroom on the port side under the bridge was designated as a "flag" stateroom, with additional staterooms for flag staff when serving as a flagship. These ships have been referred to as the Joseph Hewes-sub-class .

Bow modifications including bulwark and horizontal spray strake on USS Bowen (FF-1079) in 1984.

The Knox class had been criticized for deck wetness and there were a number of instances of damage to the forward weapons mounts in heavy seas, so the class were refitted with "hurricane bows" beginning with Bagley (FF-1069) in 1979. The modification heightened the bow section, adding bulwarks and spray strakes to prevent burrowing into on-coming seas and to better protect the forecastle armament.[12]

Aerial view of Knox-class frigate USS McCandless (FF-1084)

Twenty-five ships of the class (DE-1052, 1056, 1063–1071 and 1078–1097) were refitted with the AN/SQS-35(V) Independent Variable Depth Sonar, an active sonar operating at about 13 kHz.[5][6][7] The IVDS' sonar transducers were packaged within a 2-ton fiberglass-enclosed "fish" containing the sonar array and a gyro-compass/sensor package launched by the massive 13V Hoist from a stern compartment, located just beneath the main deck, to depths of up to 600 ft (180 m). The IVDS could take advantage of water layer temperature conditions in close-range (less than 20,000 yd (18,290 m)) submarine detection, tracking and fire-control. The AN/SQS-35 "fish" was later modified to tow an AN/SQR-18A TACTASS passive towed array sonar.[13][14] The DASH drone proved unreliable, and following its withdrawal in 1973, the ships' helicopter facilities were expanded to accommodate the larger, manned, Kaman Seasprite LAMPS 1 helicopter.[15]

Thirty-one ships (DE-1052–1069 and 1071–1083) were fitted with an eight-round Basic Point Defence Missile System (BPDMS) launcher for RIM-7 Sea Sparrow missiles in place of the cancelled Sea Mauler short range surface to air missile system, while Downes (FF-1070) was fitted with a NATO Sea Sparrow (IBPDMS) launcher. It was planned to equip the other 14 ships with Sea Chaparral, based on the Sidewinder air-to-air missile, but this plan was abandoned.[16] Most ships were refitted with a 20 mm (0.79 in) Phalanx CIWS aft during the 1980s, replacing the Sea Sparrow launcher.[13]

In the 1970s, several ships received an interim surface warfare upgrade allowing Standard ARM anti-radar missiles to be fired from the ships' ASROC launcher.[16] Later, all ships were modified to launch Harpoon anti-ship missiles from the ASROC launcher, which could carry two Harpoons, with two more carried in the ships' ASROC magazine.[13]

Five modified ships were built in Spain for the Spanish Navy as the Baleares-class. In these ships, the Sea Sparrow launcher and helicopter facilities were replaced by a Mk 22 launcher for sixteen Standard surface-to-air missiles, giving them a limited area air-defence capability.

Chi Yang class ROCN Yi Yang (FFG-939)

Chi Yang class ROCN Lan Yang (FFG-935)

Chi Yang class ROCN Yi Yang (FFG-939) has 10 SM-1 missiles installed in two forward twin box launchers on top of the helicopter hangar, and two triple box launchers installed between the stack and the hangar.

Chi Yang class ROCN Ning Yang (FFG-938)Port Left Rear View.

In the 1990s, the US agreed to transfer eight Knox-class frigates to the Republic of China Navy (ROCN). The ROCN, anticipating future difficulties in maintaining the steam plants on these ships, originally contemplated an ambitious plan to replace these plants with diesel engines. However, due to budget considerations and the acquisition of newer ships, this plan is now believed to have been shelved. These frigates were renamed the Chi Yang-class and assigned to the ROCN 168 Patrol Squadron.[17]

By 2005, the ROCN had removed several systems from the retired Gearing class upgraded World War II-vintage destroyers and transferred them to seven of the Chi Yang class. These systems include SM-1MR Standard missile in box launchers, H-930 modular combat system, DA-08 air/surface search radar, and STIR-180 illuminating radar. Each Chi Yang-class frigate has 10 SM-1 missiles installed in two forward twin box launchers on top of the helicopter hangar, and two triple box launchers installed between the stack and the hangar, pointing to port and starboard.[18] Chi Yang (FFG-932) did not receive the upgrade.

The ASW capability of the Chi Yang class is provided by its SQS-26 bow-mounted sonar, SQS-35(v) VDS, SQR-18(v)1 passive TAS, MD500 ASW helicopter, Mk-16 8-cell Harpoon/RUR-5 ASROC box launcher, and four Mk46 324 mm (12.8 in) torpedoes. While on ASW patrol, the frigate will carry two Harpoon SSMs and six ASROCs in its Mk-16 box launcher.[19]

There are some speculations that these ships will probably be upgraded with Hsiung Feng III missiles.[20]

Regarding to the outdated battle system onboard and the ageing ships, the class is expected to be replaced by the newly built Light Frigate. [21]

• List of naval ship classes in service

Wikimedia Commons has media related to Knox class frigates.

• "Knox Class Frigate". Destroyer History Foundation. Archived from the original on 25 July 2011.
• "Knox Class Frigate". Global Security.
• "Knox Class Frigate". Federation of American Scientists.
• "Knox Class Frigate Preservation Association". kcfpa.org. Archived from the original on 20 March 2015. Retrieved 12 May 2015.