TWA Flight 800

Search-and-recovery operations were conducted by federal, state and local agencies, as well as by government contractors.[1]^{: 363–365} Personnel in an HH-60 Pave Hawk helicopter of the New York Air National Guard witnessed the explosion from about eight miles away and arrived at the scene of the explosion while debris was still falling into the water, forcing the crew to retreat. They reported their sighting to the tower at Suffolk County Airport. Remotely operated vehicles (ROVs), side-scan sonar and laser line-scanning equipment were employed to search for and investigate underwater debris fields. Victims and wreckage were recovered by scuba divers and ROVs. Later, scallop trawlers were used to recover wreckage embedded in the sea floor.[1]^: 63 In one of the largest diver-assisted salvage operations ever conducted, often working in very difficult and dangerous conditions, more than 95% of the airplane wreckage was eventually recovered.[32][33]^: 1 The search-and-recovery effort identified three main areas of wreckage underwater, which were classified by color.[1]^: 65 The yellow, red and green zones contained wreckage from front, center and rear sections of the airplane, respectively.[1]^: 65–74 The green zone with the aft portion of the aircraft was located the farthest along the flight path.[1]^: 71–74

Wreckage recovered with tangled and damaged wires attached[1]^{: fig.24, p.80}

Pieces of wreckage were transported by boat to shore and then by truck to leased hangar space at the former Grumman Aircraft facility in Calverton, New York for storage, examination and reconstruction.[1]^: 63 The facility became the command center and headquarters for the investigation.[1]^{: 363–365} NTSB and FBI personnel were present to observe all transfers to preserve the evidentiary value of the wreckage.[1]^: 367 The cockpit voice recorder and flight data recorder were recovered by U.S. Navy divers one week after the accident, and the machines were immediately shipped to the NTSB laboratory in Washington, D.C. for analysis.[1]^: 58 The victims' remains were transported to the Suffolk County Medical Examiner's office in Hauppauge, New York.[34]^: 2

Relatives of TWA 800 passengers and crew, as well as the media, gathered at the Ramada Plaza JFK Hotel.[35] Many waited until the remains of their family members had been recovered, identified and released.[36]^: 1[37]^: 3–4 This hotel became known as the "Heartbreak Hotel" for its role in hosting families of victims of several airliner crashes.[38][39][40]

Many grieving relatives became angry because of TWA's delayed confirmation of the passenger list,[35] conflicting information from agencies and officials[41]^: 1 and mistrust of the recovery operation's priorities.[42]^: 2 Although NTSB vice chairman Robert Francis stated that all bodies were retrieved as soon as they were spotted and that wreckage was recovered only if divers believed that victims were hidden underneath,[42]^: 2 many families were suspicious that investigators were not truthful or were withholding information.[42]^: 2[43]^: 7[41]^: 1–2

Anger and political pressure was also directed at Suffolk County medical examiner Charles V. Wetli as recovered bodies backlogged at the morgue.[33]^: 3[43]^: 5[41]^: 1–2 Under constant pressure to identify victims with minimal delay,[34]^: 3 pathologists worked long hours. While some victims' bodies were generally intact, most others were burned, fragmented, skeletonized or decaying, necessitating identification using DNA testing and dental records.[43]^: 5 As the primary objective was to identify all remains rather than to perform detailed forensic autopsies, the thoroughness of the examinations was highly variable.[34]^: 3 Ultimately, remains of all 230 victims were recovered and identified, and the final victim identification occurred more than 10 months after the crash.[34]^: 2

With lines of authority unclear, differences in agendas and culture between the FBI and NTSB resulted in discord.[43]^: 1 The FBI, assuming that a criminal act had occurred,[43]^: 3 saw the NTSB as indecisive. Expressing frustration at the NTSB's unwillingness to speculate on a cause, one FBI agent described the NTSB as "No opinions. No nothing."[43]^: 4 Meanwhile, the NTSB was required to refute or minimize speculation about conclusions and evidence, frequently supplied to reporters by law-enforcement officials and politicians.[33]^: 3[43]^: 4 The International Association of Machinists and Aerospace Workers, an invited party to the NTSB investigation, criticized the undocumented removal by FBI agents of wreckage from the hangar where it was stored.[44]

An FBI witness statement summary (with personal information redacted)[45]^: 41

Although considerable discrepancies existed among the many witness accounts, most had seen a "streak of light," described by 38 of 258 witnesses as ascending,[1]^: 232 moving to a point where a large fireball appeared. Several witnesses reported that the fireball divided into two parts as it descended toward the water.[1]^: 3 Intense public interest arose regarding the witness reports, as did much speculation that the reported streak of light was a missile that had struck TWA 800, causing the airplane to explode.[1]^: 262 These witness accounts were a major reason for the initiation and duration of the FBI's criminal investigation.[46]^: 5

Approximately 80 FBI agents conducted interviews with potential witnesses daily.[46]^: 7 No verbatim records of the witness interviews were produced; instead, the agents who conducted the interviews wrote summaries that they then submitted.[46]^: 5 Witnesses were not asked to review or correct the summaries.[46]^: 5 Included in some of the witness summaries were drawings or diagrams of what the witnesses had observed.[45]^: 165[47]^: 184

Within days of the crash, the NTSB announced its intent to form its own witness group and to interview witnesses to the crash.[46]^: 6 After the FBI raised concerns about nongovernmental parties in the NTSB's investigation having access to this information and possible prosecutorial difficulties resulting from multiple interviews of the same witnesses,[46]^: 6 the NTSB deferred and did not interview witnesses. A safety board investigator later reviewed FBI interview notes and briefed other board investigators on their contents. In November 1996, the FBI agreed to allow the NTSB access to summaries of witness accounts in which personally identifying information had been redacted and to conduct a limited number of witness interviews. In April 1998, the FBI provided the NTSB with the identities of the witnesses, but because of the time that had elapsed, a decision was made to rely on the original FBI documents rather than on reinterviewed witnesses.[1]^: 229

Investigators considered several possible causes for the structural breakup: structural failure and decompression, detonation of a high-energy explosive device such as a missile warhead exploding either upon impact with the airplane or just before impact, a bomb exploding inside the airplane or a fuel-air explosion in the center-wing fuel tank.[1]^{: 256–257}

Close examination of the wreckage revealed no evidence of structural faults such as fatigue, corrosion or mechanical damage that could have caused the in-flight breakup.[1]^: 257 The breakup could have been initiated by an in-flight separation of the forward cargo door as had occurred in the Turkish Airlines Flight 981 or United Airlines Flight 811 accidents, but all evidence indicated that the door was closed and locked at impact.[1]^: 257 The NTSB concluded that "the in-flight breakup of TWA flight 800 was not initiated by a pre-existing condition resulting in a structural failure and decompression."[1]^: 257

A review of recorded data from long-range and airport surveillance radars revealed multiple contacts of airplanes or objects in TWA 800's vicinity at the time of the accident.[1]^: 87–89 None of these contacts intersected TWA 800's position at any time.[1]^: 89 Attention was drawn to data from the Islip, New York ARTCC facility that showed three tracks in the vicinity of TWA 800 that did not appear in any of the other radar data.[1]^: 93 None of these sequences intersected TWA 800's position at any time.[1]^: 93 None of the reviewed data showed radar returns consistent with a missile or other projectile traveling toward TWA 800.[1]^: 89

The NTSB addressed allegations that the Islip radar data showed groups of military surface targets converging in a suspicious manner in an area around the accident and that an unidentified 30-knot radar track, 3 nautical miles (5.6 km; 3.5 mi) from the crash site, was involved in foul play, as evidenced by its failure to divert from its course and assist with the search-and-rescue operations.[1]^: 93 Military records examined by the NTSB showed no military surface vessels within 15 nautical miles (28 km; 17 mi) of TWA 800 at the time of the accident.[1]^: 93 In addition, the records indicated that the closest area scheduled for military use, warning area W-387A/B, was 160 nautical miles (296 km; 184 mi) south.[1]^: 93

The NTSB reviewed the 30-knot target track to determine why it had not diverted from its course to proceed to the area where the TWA 800 wreckage had fallen. TWA 800 was behind the target, and with the target's occupants likely looking forward, they would not have been in a position to observe the aircraft's breakup, subsequent explosions or fireballs.[1]^: 94 The occupants of the target track were unlikely to have been able to hear the explosions over the sound of their craft's engines and the noise of the hull traveling through water, especially if the occupants were in an enclosed bridge or cabin.[1]^: 94 Further, review of the Islip radar data for similar summer days and nights in 1999 indicated that the 30-knot track was consistent with normal commercial fishing, recreational and cargo-vessel traffic.[1]^: 94

• Recorded radar data
• 
  Radar data showing vehicle and/or object tracks within 10 nautical miles (19 km; 12 mi) of TWA flight 800 just before the accident.[1]^{: fig. 25, p. 90}
• 
  Three sequences of primary returns near TWA 800 that were only recorded by the Islip radar.[1]^{: fig. 26, p. 91}
• 
  Primary radar returns that appeared near the TWA 800 after 8:31:12 p.m.: The 30-knot track is at the bottom center of the image.[1]^{: fig. 27, p. 92}

Trace amounts of explosive residue were detected on three samples of material from three separate locations of the recovered airplane wreckage (described by the FBI as a piece of canvas-like material and two pieces of a floor panel).[1]^: 118 These samples were submitted to the FBI's laboratory in Washington, D.C., which determined that one sample contained traces of cyclotrimethylenetrinitramine (RDX), another nitroglycerin and the third a combination of RDX and pentaerythritol tetranitrate (PETN);[1]^: 118 these findings received much media attention.[49][50] In addition, the backs of several damaged passenger seats were observed bearing an unknown red/brown-shaded substance.[1]^: 118 According to the seat manufacturer, the locations and appearance of the substance were consistent with adhesive used in the construction of the seats, and additional laboratory testing by NASA identified the substance as consistent with adhesives.[1]^: 118

Further examination of the airplane structure, seats and other interior components found no damage typically associated with a high-energy explosion of a bomb or missile warhead ("severe pitting, cratering, petalling or hot-gas washing").[1]^: 258 This included the pieces on which trace amounts of explosives were found.[1]^: 258 Of the 5% of the fuselage that was not recovered, none of the missing areas was large enough to have covered all of the damage that would have been caused by the detonation of a bomb or missile.[1]^: 258 None of the victims' remains showed any evidence of injuries that could have been caused by high-energy explosives.[1]^: 258

The NTSB considered the possibility that the explosive residue was the result of contamination from the aircraft's use in transporting troops during the Gulf War in 1991 or its use in a dog-training explosive-detection exercise about one month before the accident.[1]^{: 258–259} Testing conducted by the FAA's Technical Center indicated that residues of the type of explosives found on the wreckage would dissipate completely after two days of immersion in sea water (nearly all recovered wreckage was immersed longer than two days).[1]^: 259 The NTSB concluded that it was "quite possible" that the explosive residue detected was transferred from military ships, ground vehicles or the clothing and boots of military personnel onto the wreckage during or after the recovery operation, and that the residue was not present when the aircraft crashed into the water.[1]^: 259

Although it was unable to determine the exact source of the trace amounts of explosive residue found in the wreckage, the lack of any other corroborating evidence associated with a high-energy explosion led the NTSB to conclude that "the in-flight breakup of TWA flight 800 was not initiated by a bomb or missile strike."[1]^: 259

The wing center section of a Boeing 747-100, including the CWT[1]^{: fig. 4a, p. 13}

Scale-model test of a CWT fuel/air vapor explosion

To evaluate the sequence of structural breakup of the airplane, the NTSB formed the Sequencing Group,[1]^: 100 which examined individual pieces of the recovered structure, two-dimensional reconstructions or layouts of sections of the airplane and various-sized three-dimensional reconstructions of portions of the aircraft.[1]^: 100 In addition, the locations of pieces of wreckage at the time of recovery and differences in fire effects on pieces that are normally adjacent to each other were evaluated.[1]^: 100 The Sequencing Group concluded that the first event in the breakup sequence was a fracture in the wing center section of the aircraft caused by an "overpressure event" in the center-wing fuel tank (CWT).[51]^: 29 An overpressure event was defined as a rapid increase in pressure resulting in failure of the structure of the CWT.[1]^: 85

Because no evidence was found that an explosive device detonated in this (or any other) area of the airplane, the overpressure event could only have been caused by a fuel-air explosion in the CWT.[1]^: 261 There were 50 US gal (190 L) of fuel in the CWT of TWA 800;[52] tests recreating the flight conditions showed the combination of liquid fuel and fuel-air vapor to be flammable.[1]^: 261 A major reason for the flammability of the fuel-air vapor in the CWT of the 747 was the large amount of heat generated and transferred to the CWT by air-conditioning packs located directly below the tank;[1]^: 298 with the CWT temperature raised to a sufficient level, a single ignition source could cause an explosion.[1]^: 298

Computer modeling[1]^{: 122–123} and scale-model testing[1]^: 123 were used to predict and demonstrate how an explosion would progress in a 747 CWT. During this time, quenching was identified as an issue, a phenomenon in which the explosion would extinguish itself as it passed through the complex structure of the CWT.[1]^: 123 Because the research data regarding quenching were limited, a complete understanding of quenching behavior was not possible, and the issue of quenching remained unresolved.[1]^: 137

To better determine whether a fuel-air vapor explosion in the CWT would generate sufficient pressure to break apart the fuel tank and lead to the destruction of the airplane, tests were conducted in July and August 1997 using a retired Air France 747 at Bruntingthorpe Airfield, England. These tests simulated a fuel-air explosion in the CWT by igniting a propane-air mixture, which resulted in the failure of the tank structure from overpressure.[1]^: 261 While the NTSB acknowledged that the test conditions at Bruntingthorpe were not fully comparable to the conditions that existed on TWA 800,[1]^: 261 previous fuel explosions in the CWTs of commercial airliners such as those of Avianca Flight 203 and Philippine Airlines Flight 143 confirmed that a CWT explosion could break apart the fuel tank and lead to the destruction of an airplane.[1]^: 261

Ultimately, based on "the accident airplane's breakup sequence; wreckage damage characteristics; scientific tests and research on fuels, fuel tank explosions, and the conditions in the CWT at the time of the accident; and analysis of witness information,"[1]^: 271 the NTSB concluded that "the TWA flight 800 in-flight breakup was initiated by a fuel/air explosion in the CWT."[1]^: 63

• Debris fields
• 
  Map showing the locations of the red, yellow and green zones[1]^{: fig. 22a, p. 66}
• 
  Wreckage found in each zone corresponded to specific areas of the aircraft[1]^{: fig. 22b, p. 67}
• 
  The pathways the wreckage took as it fell to the ocean[1]^{: fig. 22c, p. 68}

Slide from NTSB presentation of TWA 800 breakup sequence, illustrating structure and size of CWT

Recovery locations of the wreckage from the ocean (the red, yellow and green zones) clearly indicated: (1) the red area pieces (from the forward portion of the wing center section and a ring of fuselage directly in front) were the earliest pieces to separate from the airplane; (2) the forward fuselage section departed simultaneously with or shortly after the red area pieces, landing relatively intact in the yellow zone; (3) the green area pieces (wings and the aft portion of the fuselage) remained intact for a period after the separation of the forward fuselage and impacted the water in the green zone.[51]^: 3–4

Frame from the CIA's animated depiction of how TWA Flight 800 broke apart: When the bottom of the aircraft blew out from the exploding fuel tank, cracks spread around the fuselage and severed the entire front section of the plane.

Fire damage and soot deposits on the recovered wreckage indicated that some areas of fire existed on the airplane as it continued in crippled flight after the loss of the forward fuselage.[1]^: 109 After about 34 seconds (based on information from witness documents), the outer portions of both the right and left wings failed.[1]^{: 109, 263} Shortly after, the left wing separated from what remained of the main fuselage, which resulted in further development of the fuel-fed fireballs as the pieces of wreckage fell to the ocean.[1]^: 263

Only the FAA radar facility in North Truro, Massachusetts, using specialized processing software from the United States Air Force 84th Radar Evaluation Squadron, was capable of estimating the altitude of TWA 800 after it lost power due to the CWT explosion.[1]^: 87 Because of accuracy limitations, these radar data could not be used to determine whether the aircraft climbed after the nose separated.[1]^: 87 Instead, the NTSB conducted a series of computer simulations to examine the flightpath of the main portion of the fuselage.[1]^: 95–96 Hundreds of simulations were run using various combinations of possible times the nose of TWA 800 separated (the exact time was unknown), different models of the behavior of the crippled aircraft (the aerodynamic properties of the aircraft without its nose could only be estimated), and longitudinal radar data (the recorded radar tracks of the east/west position of TWA 800 from various sites differed).[1]^: 96–97 These simulations indicated that after the loss of the forward fuselage the remainder of the aircraft continued in crippled flight, then pitched up while rolling to the left (north),[1]^: 263 climbing to a maximum altitude between 15,537 and 16,678 feet (4,736 and 5,083 m)[1]^: 97 from its last recorded altitude, 13,760 feet (4,190 m).[1]^: 256

Most witness observations of a streak of light were determined by the NTSB to be consistent with the calculated flightpath of TWA 800 after the CWT explosion (screenshot from an NTSB animation).

At the start of FBI's investigation, because of the possibility that international terrorists might have been involved, assistance was requested from the Central Intelligence Agency (CIA).[53]^: 2 CIA analysts, relying on sound-propagation analysis, concluded that the witnesses could not be describing a missile approaching an intact aircraft, but were seeing a trail of burning fuel coming from the aircraft after the initial explosion.[53]^: 5–6 This conclusion was reached after calculating how long the sound of the initial explosion took to reach the witnesses, and using that to correlate the witness observations with the accident sequence.[53]^: 5 In all cases, the witnesses could not be describing a missile approaching an intact aircraft, as the plane had already exploded before their observations began.[53]^: 6

As the investigation progressed, the NTSB decided to form a witness group to more fully address the accounts of witnesses.[46]^: 7 From November 1996 through April 1997, this group reviewed summaries of witness accounts on loan from the FBI (with personal information redacted) and conducted interviews with crewmembers from a New York Air National Guard HH-60 helicopter and C-130 airplane, as well as a U.S. Navy P-3 airplane that was flying in the vicinity of TWA 800 at the time of the accident.[46]^: 7–8

In February 1998, the FBI, having closed its active investigation, agreed to fully release the witness summaries to the NTSB.[46]^: 10 With access to these documents no longer controlled by the FBI, the NTSB formed a second witness group to review the documents.[46]^: 10 Because of time that had elapsed (about 21 months) before the NTSB received information about the identity of the witnesses, the witness group chose not to reinterview the witnesses, but instead to rely on the original summaries of witness statements written by FBI agents as the best available evidence of the observations initially reported by the witnesses.[1]^: 230 Despite the two and a half years that had elapsed since the accident, the witness group did interview the captain of Eastwind Airlines Flight 507, who was the first to report the explosion of TWA 800, because of his vantage point and experience as an airline pilot.[46]^: 12[54]

A frame from the NTSB's animation depicting how the noseless plane climbed erratically before descending into the ocean

The NTSB's review of the released witness documents determined that they contained 736 witness accounts, of which 258 were characterized as "streak of light" witnesses ("an object moving in the sky... variously described [as] a point of light, fireworks, a flare, a shooting star, or something similar.")[1]^: 230 The NTSB witness group concluded that the streak of light reported by witnesses might have been the actual airplane during some stage of its flight before the fireball developed, noting that most of the 258 streak-of-light accounts were generally consistent with the calculated flightpath of the accident airplane after the CWT explosion.[1]^: 262

Thirty-eight witnesses described a streak of light that ascended vertically, or nearly so, and these accounts "seem[ed] to be inconsistent with the accident airplane's flightpath."[1]^: 265 In addition, 18 witnesses reported seeing a streak of light that originated at the surface, or the horizon, which did not "appear to be consistent with the airplane's calculated flightpath and other known aspects of the accident sequence."[1]^: 265 Regarding these differing accounts, the NTSB noted that based on their experience in previous investigations "witness reports are often inconsistent with the known facts or with other witnesses' reports of the same events."[1]^: 237 The interviews conducted by the FBI focused on the possibility of a missile attack; suggested interview questions given to FBI agents such as "Where was the sun in relation to the aircraft and the missile launch point?" and "How long did the missile fly?" could have biased interviewees' responses in some cases.[1]^: 266 The NTSB concluded that given the large number of witnesses in this case, they "did not expect all of the documented witness observations to be consistent with one another"[1]^: 269 and "did not view these apparently anomalous witness reports as persuasive evidence that some witnesses might have observed a missile."[1]^: 270

After missile visibility tests were conducted in April 2000, at Eglin Air Force Base, Fort Walton Beach, Florida,[1]^: 254 the NTSB determined that if witnesses had observed a missile attack, they would have seen:

1. a light from the burning missile motor ascending very rapidly and steeply for about 8 seconds
2. the light disappearing for up to 7 seconds
3. upon the missile striking the aircraft and igniting the CWT, another light, moving considerably more slowly and more laterally than the first, for about 30 seconds
4. this light descending while simultaneously developing into a fireball falling toward the ocean[1]^: 270 None of the witness documents described such a scenario.[1]^: 270

Another frame from the CIA's animation depicting how the left wing of TWA Flight 800 was shorn off and created a second fireball

Because of their unique vantage points or the level of precision and detail provided in their accounts, five witness accounts generated special interest:[1]^{: 242–243} the pilot of Eastwind Airlines Flight 507, the crew members in the HH-60 helicopter, a streak-of-light witness aboard US Airways Flight 217, a land witness on the Beach Lane Bridge in Westhampton Beach, New York and a witness on a boat near Great Gun Beach.[1]^{: 243–247} Advocates of a missile-attack scenario asserted that some of these witnesses observed a missile;[1]^: 264 analysis demonstrated that the observations were not consistent with a missile attack on TWA 800, but instead were consistent with these witnesses having observed part of the in-flight fire and breakup sequence after the CWT explosion.[1]^: 264

The NTSB concluded, "the witness observations of a streak of light were not related to a missile and that the streak of light reported by most of these witnesses was burning fuel from the accident airplane in crippled flight during some portion of the postexplosion, preimpact breakup sequence".[1]^: 270 The NTSB further concluded, "the witnesses' observations of one or more fireballs were of the airplane's burning wreckage falling toward the ocean".[1]^: 270

To determine what ignited the flammable fuel-air vapor in the CWT and caused the explosion, the NTSB evaluated numerous potential ignition sources. All but one were considered very unlikely to have been the source of ignition.[1]^: 279

Although the NTSB had already reached the conclusion that a missile strike did not cause the structural failure of the airplane, the possibility that a missile could have exploded close enough to TWA 800 for a missile fragment to have entered the CWT and ignited the fuel/air vapor, yet far enough away not to have left any damage characteristic of a missile strike, was considered.[1]^: 272 Computer simulations using missile performance data simulated a missile detonating in a location such that a fragment from the warhead could penetrate the CWT.[1]^: 273 Based on these simulations, the NTSB concluded that it was "very unlikely" that a warhead could have detonated in such a location where a fragment could penetrate the CWT without other missile fragments impacting the surrounding airplane structure, leaving distinctive impact marks.[1]^: 273

Similarly, the investigation considered the possibility that a small explosive charge placed on the CWT could have been the ignition source.[1]^: 273 Testing by the NTSB and the British Defence Evaluation and Research Agency demonstrated that when metal of the same type and thickness of the CWT was penetrated by a small charge, petalling of the surface occurred where the charge was placed, with pitting on the adjacent surfaces and visible hot-gas washing damage in the surrounding area.[1]^{: 273–274} Since none of the recovered CWT wreckage exhibited these damage characteristics and none of the areas of missing wreckage was large enough to encompass all the expected damage, the investigation concluded that this scenario was "very unlikely".[1]^: 274

The NTSB also investigated whether the fuel-air mixture in the CWT could have been ignited by lightning strike, meteor strike, auto ignition or hot surface ignition, a fire migrating to the CWT from another fuel tank via the vent system, an uncontained engine failure, a turbine burst in the air conditioning packs beneath the CWT, a malfunctioning CWT jettison/override pump, a malfunctioning CWT scavenger pump, or static electricity.[1]^{: 272–279} After analysis, the investigation determined that these potential sources were "very unlikely" to have been the source of ignition.[1]^: 279

Because a combustible fuel-air mixture will always exist in fuel tanks, Boeing designers had attempted to eliminate all possible sources of ignition in the 747's tanks. To do so, all devices are protected from vapor intrusion, and voltages and currents used by the fuel quantity indication system (FQIS) are kept very low. In the case of the 747-100 series, the only wiring located inside the CWT is that associated with the FQIS.

For the FQIS to have been Flight 800's ignition source, a transfer of higher-than-normal voltage to the FQIS would have needed to occur, as well as some mechanism whereby the excess energy was released by the FQIS wiring into the CWT. The NTSB concluded, "the ignition energy for the CWT explosion most likely entered the CWT through the FQIS wiring."[1]^: 294[55]

Though the FQIS itself was designed to prevent danger by minimizing voltages and currents, the innermost tube of Flight 800's FQIS compensator showed damage similar to that of the compensator tube identified as the ignition source for the surge tank fire that destroyed a 747 near Madrid in 1976.[1]^{: 293–294} This was not considered proof of a source of ignition. Evidence of arcing was found in a wire bundle that included FQIS wiring connecting to the center wing tank.[1]^: 288 Arcing signs were also seen on two wires sharing a cable raceway with FQIS wiring at station 955.[1]^: 288

The captain's CVR channel showed two "dropouts" of background power harmonics in the second before the recording ended (with the separation of the nose).[1]^: 289 This might well be the signature of an arc on cockpit wiring adjacent to the FQIS wiring. The captain commented on the "crazy" readings of the number 4 engine fuel flow gauge about 2 1/2 minutes before the CVR recording ended.[1]^: 290 Finally, the CWT fuel quantity gauge was recovered and indicated 640 pounds instead of the 300 pounds that had been loaded into that tank.[1]^: 290 Experiments showed that applying power to a wire leading to the fuel quantity gauge can cause the digital display to change by several hundred pounds before the circuit breaker trips. Thus, the gauge anomaly could have been caused by a short to the FQIS wiring.[1]^: 290 The NTSB concluded that the most likely source of sufficient voltage to cause ignition was a short from damaged wiring, or within electrical components of the FQIS. As not all components and wiring were recovered, pinpointing the source of the necessary voltage was not possible.

The NTSB's conclusions about the cause of the TWA 800 disaster took four years and one month to be published. The FBI's earliest investigations and interviews, later used by the NTSB, were performed under the assumption of a missile attack, a fact noted in the NTSB's final report. Six months into the investigation, the NTSB's chairman, Jim Hall, was quoted as saying, "All three theories—a bomb, a missile, or mechanical failure—remain."[57] Speculation was fueled in part by early descriptions, visuals, and eyewitness accounts of the disaster that indicated a sudden explosion and trails of fire moving in an upward direction.

On June 19, 2013, the NTSB acknowledged in a press release that they received a petition for reconsideration of its investigation into the July 17, 1996, crash of TWA Flight 800.[58] In 2014, the NTSB declined the petition to reopen the investigation.[59] In a press release, the NTSB stated: "After a thorough review of all the information provided by the petitioners, the NTSB denied the petition in its entirety because the evidence and analysis presented did not show the original findings were incorrect."[60]

TWA Memorial

The TWA Flight 800 International Memorial was dedicated in a 2-acre (8,100 m²) parcel immediately adjoining the main pavilion at Smith Point County Park in Shirley, New York, on July 14, 2004. Funds for the memorial were raised by the Families of TWA Flight 800 Association. The memorial includes landscaped grounds, flags from the 13 countries of the victims and a curved black granite memorial with the names engraved on one side and an illustration on the other of a wave releasing 230 seagulls. In July 2006, an abstract black granite statue of a 10-foot-high (3.0 m) lighthouse was added above a tomb holding many of the victims' personal belongings. The lighthouse statue was designed by Harry Edward Seaman, whose cousin died in the crash, and dedicated by George Pataki.[72]

For almost 25 years, the wreckage of Flight 800 was kept by the NTSB and used as an accident-investigation teaching aid. By 2021, the methods taught using the wreckage were determined to no longer be relevant to modern accident investigation, which by then relied heavily on new technology, including three-dimensional laser-scanning techniques.[73] As the NTSB did not wish to renew the lease for the hangar in which it had stored the reassembled accident debris, it decommissioned the wreckage in July 2021.[74] As the NTSB had agreements with the victims' families that the wreckage cannot be used in any kind of public memorial or be scuttled in the ocean, it plans to scan each piece of debris with a three-dimensional laser scanner, with the data being permanently archived, after which the wreckage will be destroyed and the metal recycled. Any parts of the plane that cannot be recycled will be disposed of in landfills.[75][76] Destruction of the wreckage was scheduled for completion before the end of 2021.[74]