Regional jet

In 1959 was introduced the Sud Aviation Caravelle (80 to 140 seats), ordered by Flag Carriers, the first purpose-built short-haul jetliner, a twin turbojet design for inter-European routes. The Caravelle used the forward fuselage nose section of the de Havilland Comet, the first commercial jetliner, not effective for continental-European flights. The BAC One-Eleven (89 to 119 seats) was then introduced in 1965.

In 1968, Aeroflot introduced the 32-seat Yakovlev Yak-40 and the 65- to 85-seat Fokker F28 Fellowship was introduced in 1969. In 1975, the 40- to 44-seat VFW-Fokker 614 saw service entry with its distinctive overwing engines, 19 were built. Some business jets like the British Aerospace 125 (first delivery: 1964) and Dassault Falcon 20 (1965) were operated by small airlines from the 1960s, and the small Aerospatiale Corvette (1974) was used as a regional airliner from the 1970s.

The Bae 146 started service in May 1983

In 1978, the US Airline Deregulation Act led to route liberalization, favouring small airliners demand. US passengers were disappointed by these, lacking aircraft lavatories or flight attendants of larger jet aircraft. As feeder routes grew, regional airlines replaced these small aircraft with larger turboprop airliners to feed larger airline hubs. These medium airliners were then supplanted by faster, longer range, regional jets like the first Bombardier CRJ100/200. Early small jets had higher operating costs than turboprops on short routes. The gap narrowed with better turbofans, and closed with the higher utilization due to higher speeds.

In 1983 British Aerospace introduced its BAe 146 short-range jet, produced in three sizes between 70 and 112 seats: the -100, -200, and the largest -300, later renamed the Avro Regional Jet. Low aircraft noise and short takeoffs were suited to city-center to city-center service, a small market niche, like the de Havilland Canada Dash 7, but four engines led to higher maintenance costs than twin-engine designs and BAe did not produce a lower operating cost twin-engine design, unlike the Dash 8.

In 1988, the 97- to 122-seat Fokker 100, a stretched F28, was introduced, followed by the shorter, 72– to 85-seat Fokker 70 in 1994.

The Bombardier CRJ-100 was introduced in 1992 and was stretched in the CRJ700 series

The Embraer ERJ family began in April 1997

Low fuel prices drove the development of the regional jet: in the 1990s oil prices were around $10–20 per barrel. Turboprop manufacturers wanted to develop their portfolio. Canadair's purchase by Bombardier in 1986 enabled a 50-seat stretched development of its Challenger business jet, green-lighted by then chief executive Laurent Beaudoin in March 1989. The first Bombardier four-abreast Canadair Regional Jet was delivered in October 1992 to Lufthansa CityLine.[10]

Embraer then developed the 50-seat three-abreast ERJ 145 from the EMB-120 Brasilia turboprop, which was introduced in December 1996. They replaced the turboprops thanks to their better perceived image and larger range. On small-capacity long routes, they could offer a better service by increasing frequencies at a smaller capacity and could replace mainline jet airliners like McDonnell Douglas DC-9s and Boeing 737s.[10] They can be used for direct airport-to-airport flights, to the detriment of the hub-and-spoke model.

Since 1999, the Fairchild Dornier 328JET was also competing but the type did not enter large scale production as Fairchild Dornier went bankrupt, also ending the larger Fairchild Dornier 728 family development. The CRJ/ERJ also resulted in the end of the BAe 146 line.

The CRJ and ERJ success also played a minor part in the failure of Fokker, whose Fokker 100 found itself squeezed on both sides by new models of the Boeing 737 and Airbus A319 on the "large" side and the RJs on the "small side". On 5 February 1996, Bombardier started looking at a takeover of a struggling Fokker, producer of the Fokker 100 100-seater. After evaluating Fokker's opportunities and challenges, Bombardier dropped the prospect on 27 February.[11] Bombardier was feeling that the 100-seat market was already saturated by designs like the A319, a decision that looked foolish with the successful introduction of the E-Jets.

The Embraer E-Jet family was introduced in 2004 and was followed by the E-Jet E2

The share of US domestic passengers flying in 32- to 100-seat regional jets grew to one-third from 2000 to 2005, as network carriers subcontracted low-volume routes to cheaper commuter airlines with smaller planes. Amid regional jet usage saturation, bankruptcy of regional airlines and shrinking of Delta Air Lines and Northwest Airlines, cramped 50-seaters were evolving into more spacious 70- to 100-seaters, limited by union rules.[12]

In late 2005, Bombardier suspended its CRJ-200 production line.[13]

Between 2000 through 2006, 385 large planes were grounded while 1,029 regional jets were added.[14] By June 2007, nearly a third of US domestic flights on major airlines were late, as using more smaller jets led to more crowded skies and runways in an already saturated system.[15]

US major carriers high pilots' wages led them to subcontract flights to regional airlines with lower labor costs. Pilot unions then demanded to regulate subcontracted aircraft size to a 50 seats maximum scope clause. In turn, large routes were served by sub-optimal 50-seat jets which accelerated demand for those types in North America. Embraer envisioned a market for more than 500 aircraft and planned to produce up to 80 a year, but at peak delivered 157 ERJs in 2000 while Bombardier delivered 155 CRJs in 2003.[10]

After 9/11, high fuel prices returned and jets had to grow to keep seat-mile costs down. Airlines renegotiated scope clause to limit jets to 70 seats as the market consolidated. Larger aircraft came back on regional routes for their efficiency, and on shorter routes turboprops were not much slower for a lower cost, reversing the 1990s trend. Bombardier delivered its last 50-seat CRJ in 2006 and Embraer delivered its last ERJ in 2011.[10]

Bombardier switched to its lengthened 70- to 100-seat CRJ700/900/1000, while Embraer launched the four-abreast E-Jet series 170/175/190/195. 50-seat jet demand is lower with high fuel prices, and this reflects on their lower market value. A majority of them will be scrapped.[10]

Bombardier and Embraer have started a series of lawsuits over export taxes and subsidies.

Although not as economical as the turboprop, by flying directly to and from smaller airports, regional jets reduced the need for low-cost regional airliners.

The 68- to 99-seat Antonov An-148, designed and produced by Antonov in Ukraine, made its maiden flight on 17 December 2004 after a development started in the 1990s. It was certified on 26 February 2007 and introduced in 2009. The stretched An-158 can seat 99 passengers.

The Sukhoi Superjet 100 was introduced in 2011

United Aircraft Corporation subsidiary Sukhoi developed the Superjet 100, it made its maiden flight on 19 May 2008 and was introduced in April 2011 with Armavia. It typically seats 98 passengers and is powered by 2 PowerJet SaM146 turbofans from a Safran/NPO Saturn joint venture.[16]

Many CRJ100/200 were retired since 2003 and in 2013 the first Embraer ERJ were disassembled: 50-seaters' value was dwindling as US carriers were dropping them.[17] The ERJ retirements could be exacerbated because Rolls-Royce plc restricts parts choice, making engine maintenance more expensive, but its TotalCare agreements provide cost predictability.[18]

The Comac ARJ21 is a 78- to 90-seat jet manufactured by the Chinese state-owned aerospace company Comac. Development began in March 2002, the first prototype was rolled out on 21 December 2007, and made its maiden flight on 28 November 2008. It received its CAAC Type Certification on 30 December 2014 and was introduced on 28 June 2016 by Chengdu Airlines. Resembling the McDonnell Douglas MD-80/MD-90 produced under licence in China, it features a 25° swept, supercritical wing designed by Antonov and twin rear-mounted General Electric CF34 engines.

Bombardier Aerospace developed the 108- to 160-seat CSeries powered by two Pratt & Whitney PW1000G geared turbofans.[19] The smaller CS100 entered service in July 2016 with Swiss Global Air Lines and the larger CS300 entered service with airBaltic in December.[20] After the April 2016 CSeries dumping petition by Boeing, Airbus acquired a 50.01% majority stake in the program in October 2017 and renamed it the A220-100/300 in July 2018.[21]

The Embraer E190-E2 was introduced in 2018

In 2017, Embraer started calling large, almost narrowbody regional jets "crossover" jets, for the Embraer E-Jet E2 and the CSeries.[22] While those rival the A320neo, the smaller MRJ and SSJ100 could be stretched.[23] They are often the largest airliners which can access city airports like London City Airport, benefiting from their longer range and lower fuel burn to open new markets while making lower noise for better local community acceptance.[24]

In 2019, after attempting to renegotiate scope clauses, United Airlines ultimately decided to order fifty CRJs for its regional affiliates; the aircraft will be sourced from existing CRJ700 airframes and reconfigured with 50 seats in 3 classes. Bombardier will recertify the aircraft as the CRJ550 model, with a lower MTOW to comply with the scope clauses, and hopes to sell this new configuration to replace up to 700 existing 50-seaters with US regional airlines.[25][26]

By August 2019, there were 1,100 50-seat jets operated worldwide including 700 in the US, many more than 20 years old. SkyWest wants to replace 150 of its 200 ageing Bombardier CRJ200s and ERJs and while many have logged 30,000 cycles, their life may be extended to 60,000 cycles for 10-15 more years of service. SkyWest asked Bombardier, Embraer and Mitsubishi Aircraft to develop a new aircraft but the market is regulated by scope clauses.[27]

The Mitsubishi SpaceJet (ex MRJ), seating 70–90 passengers and manufactured by Mitsubishi Aircraft Corporation, made its first flight on 11 November 2015.[28] After several delays, the program was canceled in February 2023.[29][30] After Bombardier Aviation divested its CSeries and Dash 8 programmes, it sold the CRJ programme to Mitsubishi Heavy Industries, in a deal that closed on 1 June 2020.[31]

A smaller airplane is more costly per seat mile than a larger plane, but it mostly depends on the airline: in 2005, Bombardier was estimating regional jet costs at 9 to 10 US cents per seat mile while flying a Boeing 737 costs less than 8 cents per seat mile at Southwest Airlines but 15 cents at Continental Airlines.[32]

While designed primarily for medium stage lengths, regional jets may now be found supplementing major trunk routes alongside traditional larger jet aircraft. RJs allow airlines to open new "long, thin" routings with jet equipment which heretofore did not exist, such as Atlanta to Monterrey, Nuevo León. RJs have also meant a return of jet service to cities where full-size jet service had departed over a decade ago, such as Macon, Georgia, and Brownsville, Texas.

The idea that regional jets would provide point-to-point service and bypass the hub-and-spoke system is debated. As of January 2003, 90% of all regional jet flights in the United States had a hub or major airport at one end of that flight, and this number has been gradually increasing since 1995. However an International Center for Air Transportation Report in 2004 noted that regional jets were no longer used solely for hub feeder operations. As such they filled a gap in the market by flying on longer routes than turboprops, but shorter than the narrow body jets.[33]